Table of Contents
Advertisement
Quick Links
WARNING: FOLLOW THE INFORMATION IN
THESE INSTRUCTIONS EXACTLY, IF NOT, A FIRE
OR EXPLOSION MAY RESULT CAUSING
PROPERTY DAMAGE, PERSONAL INJURY OR
LOSS OF LIFE.
WARNING: DO NOT STORE OR USE GASOLINE
OR ANY OTHER FLAMMABLE VAPORS AND
LIQUIDS NEAR THIS OR ANY OTHER GAS
APPLIANCE.
WHAT TO DO IF YOU SMELL GAS:
Do not try to light any appliance.
Do not touch electrical switches; do not use the phone
in your building.
Immediately call your gas supplier from a phone
outside the structure. Follow your gas supplier's
instructions.
If you cannot reach your gas supplier, call the fire
department or 911.
A qualified installer, service agency, or gas supplier must
perform installation and service of this appliance. In the
Commonwealth of Massachusetts, all installation of gas
lines and gas fittings must be performed by a licensed gas
fitter or licensed plumber.
Champlain
Gas-Fired Direct Vent Heater
Owner's Manual
Operation & Installation Guide
Read This Owner's Manual
Operate and Maintain This Gas Heater
According to This Instruction Manual.
Save These Instructions!
AVERTISSEMENT:
SUIVRE
LES
INSTRUCTIONS
CETTE NOTICE POUR RÉDUIRE AU MINIMUM LE
RISQUE D'INCENDIE OU POUR ÉVITER TOUT
DOMMAGE MATÉERIEL, TOUTE BLESSURE OU
LA MORT.
AVERTISSEMENT: NE PAS ENTRESPOSER NI
UTILISER D'ESSENCE NI D'AUTRE VAPERURS
OU
LIQUIDES
INFLAMMABLES
VOISINAGE DE CET APPRAREIL OU DE TOUT
AUTRE APPAREIL.
QUE FAIRE SI VOUS SENTEZ UNE ODEUR DE GAZ:
Ne pas tenter d'allumer d'appareil.
Ne touchez à aucun interrupteur. Ne pas vous servir
des téléphones se trouvant dans le batiment où vous
vous trouvez.
Appelez immédiatement votre fournisseur de gaz
depuis un voisin. Suivez les instructions du
fournisseur.
Si vous ne pouvez rejoindre le fournisseur de gaz,
appelez le service dos incendies.
L'installation et service doit être exécuté par un qualifié
installer, agence de service ou le fournisseur de gaz.
(Model 8301)
ASSUREZ-VOUS
DE
BIEN
DONNÉ
DANS
DANS
Champlain DV Model 8301
Manual: 6400-40421
R: 2 - 7/27/11
LE
Advertisement
Table of Contents
Related Manuals for HearthStone Champlain 8301
Summary of Contents for HearthStone Champlain 8301
-
Page 1: Save These Instructions
Champlain (Model 8301) Gas-Fired Direct Vent Heater Owner’s Manual Operation & Installation Guide Read This Owner’s Manual Operate and Maintain This Gas Heater According to This Instruction Manual. Save These Instructions! WARNING: FOLLOW THE INFORMATION IN AVERTISSEMENT: ASSUREZ-VOUS BIEN THESE INSTRUCTIONS EXACTLY, IF NOT, A FIRE SUIVRE INSTRUCTIONS DONNÉ... - Page 2 Intentionally Blank Page 1 of 30...
- Page 3 Information Sheet Use this page to record all relevant information concerning the purchase, installation, and maintenance of your Champlain Model 8301 Direct -Vent heater. This information will facilitate servicing, purchase of replacement parts, and warranty claims (if necessary). Keep your original receipt in a safe place as proof of purchase. Serial Number: Fuel type: Natural Gas...
-
Page 4: Table Of Contents
Hearthstone Quality Home Heating Products, Inc CHAMPLAIN DV Model 8301 Table of Contents .......................... 4 NTRODUCTION , & S ..........................4 ARNINGS AUTIONS AFETY ........................5 PECIFICATIONS ’ ......................6 WNER NFORMATION ............................7 IGHTING NSTRUCTIONS ..........................7 PPLIANCE ..........................7 ARIABLE UTPUT ONTROL ...............................7... -
Page 5: Introduction
Hearthstone Quality Home Heating Products, Inc CHAMPLAIN DV Model 8301 NTRODUCTION Congratulations on your purchase of Hearthstone’s OBSTRUCTIONS. (S’ASSURER QUE LE BRÛLEUR ET LE COMPARTIMENT DES COMMANDES SONT Champlain DV Model 8301 Gas-Fired Direct Vent PROPRES. VOIR INSTRUCTIONS heater. The Champlain DV will provide you with D’INSTALLATION... -
Page 6: Pecifications
Hearthstone Quality Home Heating Products, Inc CHAMPLAIN DV Model 8301 PECIFICATIONS Testing Agency: Intertek Testing Services NA, Inc. Certified for use by: (ITS) Board of State Examiners of Plumbers and Gasfitters Listed: Direct Vent Gas Heater 100 Cambridge Street, Room 1511... -
Page 7: Owner ' S Information
Hearthstone Quality Home Heating Products, Inc CHAMPLAIN DV Model 8301 ’ WNER NFORMATION The installation must conform with local codes or, in Supervise young children carefully when in the same the absences of local codes, the current National room as the appliance. Do not place clothing or Fuel Gas Code, ANSI Z223.1 (NFPA 54), or... -
Page 8: Lighting Instructions
Optional remote, or programmable thermostats are If knob does not pop out when released, available for purchase from your local Hearthstone stop and immediately call a qualified service dealer. The desired room temperature is maintained technician or gas supplier. -
Page 9: Nstaller Nformation
Hearthstone Quality Home Heating Products, Inc CHAMPLAIN DV Model 8301 ’ NSTALLER NFORMATION the unit. If you detect any damage, or a missing part, ODES immediately contact your dealer. Adhere to all local codes or, in their absence, Do not install or put into service a damaged obtain the latest edition of THE NATIONAL FUEL or incomplete heater. -
Page 10: Items Required For Installation
Hearthstone Quality Home Heating Products, Inc CHAMPLAIN DV Model 8301 LEARANCES OMBUSTIBLES L-Bracket (2) Catch Always maintain clearances around the air openings in the stove. This allows for adequate ventilation. (As shown in Figures 3, through 6.) The corner clearance for the Champlain is 2”, measured from the edge of the top castings to the adjacent wall. - Page 11 Hearthstone Quality Home Heating Products, Inc CHAMPLAIN DV Model 8301 Figure 6: Snorkel Wall Clearances Figure 4: Wall Clearances Horizontal Vent CONDITIONALLY APPROVED FOR PURCHASED MOBILE HOME INSTALLATION. THIS APPLIANCE MAY BE INSTALLED IN AN AFTERMARKET PERMANENTLY LOCATED, MANUFACTURED (OR MOBILE) HOME, WHERE NOT PROHIBITED BY LOCAL CODES.
-
Page 12: Enting Nformation
Hearthstone Quality Home Heating Products, Inc CHAMPLAIN DV Model 8301 ENTING NFORMATION There many configurations vent components listed in this manual. Use the following installations for your stove. Please review the instructions along with the pipe manufacturer’s following pages for the venting installation that instructions to complete the installation. - Page 13 Hearthstone Quality Home Heating Products, Inc CHAMPLAIN DV Model 8301 Figure 8: Termination Location & Clearances A = Clearance above grade, veranda, porch, deck, H = *Not to be installed within 15 feet (4.5m) above or balcony: 12 inches (30cm) minimum.
-
Page 14: Acceptable Direct -V
Hearthstone Quality Home Heating Products, Inc CHAMPLAIN DV Model 8301 HIMNEY INER YSTEM CCEPTABLE IRECT ERMINATION OCATIONS Direct-Vent Chimney Liner Termination Kit Chimney Liner Flex The vent/air intake termination clearances above the Co-Linear Flex Connector high side of an angled roof as follows: -Axial to Co-Linear Appliance Connect (Masonry approved, not to exceed 16’... - Page 15 Hearthstone Quality Home Heating Products, Inc CHAMPLAIN DV Model 8301 screws, keeping the screws as close to the wall thimble as possible. Bend or cut the excess strapping so the thimble cover will fit properly. Screw the thimble cover to the wall.
- Page 16 Hearthstone Quality Home Heating Products, Inc CHAMPLAIN DV Model 8301 IV. H ORIZONTAL ERMINATION ENTING ONFIGURATIONS -A minimum of 24" rise is required (with or w/o -Horizontal sections require a 1/4" rise every 12" of offsets) horizontal run. -40' maximum system height (without offsets) -For each 90°...
-
Page 17: Vent Restrictor
Hearthstone Quality Home Heating Products, Inc CHAMPLAIN DV Model 8301 Figure 13: Venting Configuration and Restrictor Settings the locator, found on the rear left side of the stove ENT RESTRICTOR (Refer to figure 13 above) To adjust your restrictor for maximum flame... -
Page 18: As Upply Onnections
Use of a dedicated sediment trap (see figure 14) is required by code, and by Hearthstone. Damage to components caused by the lack of a sediment trap is not covered by warranty. -
Page 19: Log Placement
Hearthstone Quality Home Heating Products, Inc CHAMPLAIN DV Model 8301 LACEMENT Place only the decorative fiber log set supplied with the unit in the firebox. This log set is specifically designed for the provided pan burner. Do not use any other type of fiber logs, wood logs, or other materials in the firebox. -
Page 20: Removal Of Log Set
Hearthstone Quality Home Heating Products, Inc CHAMPLAIN DV Model 8301 randomly. This wool will glow brightly once the unit is running. 7. Gently slide the split log (5) onto pins C and D as shown below. 10. Replace the glass frame by sliding it down the face of the firebox and pushing the top back. -
Page 21: Lighting The Unit The First Time
DJUSTMENT the lower rear left of the stove. Light the unit and The pilot light is preset by Hearthstone and should run at highest flame setting for at least 10 minutes not need adjustment. The pilot light flame must be... -
Page 22: Gas Conversions
Hearthstone Quality Home Heating Products, Inc CHAMPLAIN DV Model 8301 Figure 17: T YPICAL LAME ATTERN ONVERSIONS Each Champlain stove is factory set for use with Natural Gas. However, conversion is easy for use with LP, and visa versa. Follow the instructions provided with the included conversion kit. -
Page 23: Routine Maintenance And Care
Hearthstone Quality Home Heating Products, Inc CHAMPLAIN DV Model 8301 OUTINE AINTENANCE AND Champlain requires minimal routine Complete the cleaning procedure by carefully maintenance and care. The unit should always be placing the log set back in the firebox as described cool and off when cleaned, or serviced. -
Page 24: Wiring Instructions
Hearthstone Quality Home Heating Products, Inc CHAMPLAIN DV Model 8301 Wiring Instructions Figure 18: Champlain 8301 Wiring Detail CAUTION: LABEL ALL WIRES PRIOR TO ATTENTION: AU MOMENT DE L’ENTRETIEN DES DISCONNECTION WHEN SERVICING COMMANDES, ÉTIQUETEZ TOUS LES FILS CONTROLS. WIRING ERRORS CAN CAUSE AVANT LE DÉBRANCHEMENT. -
Page 25: Parts List
REMOTE CONTROL THERMOSTAT # (90-56914) WARNING! DO NOT SUBSTITUTE MATERIALS. For replacement parts, or for information about parts or service, contact your authorized Hearthstone retailer. For the name of the authorized retailer nearest to you, visit our website at www.hearthstonestoves.com. -
Page 26: Rating Label
115 VOLTS, LESS THAN 2.0A EDGE OF SIDE TO: SIDEWALL 4” / 100 mm Several Optional kits are available through HearthStone or your local HearthStone dealer. A blower assembly may be used (kit # 93-57010) , two different remote controls (kit #90-56912 & kit #90-56914) are optional as well. -
Page 27: Roubleshooting
ROUBLESHOOTING Symptom Possible Cause Corrective Action 1. Pilot will not A. Using the piezo sparker, try to light the pilot. If it will not A. Insufficient gas pressure, light. light, check the inlet gas pressure. air in the pilot line, or dirty or kinked gas line. - Page 28 Symptom Possible Cause Corrective Action 3. Pilot burning, no A. Thermostat switch or A. Check thermostat/wiring for proper connections. Place gas to main burner, wires defective. jumper wire across terminals at thermostat. If burner comes valve knob in the on, replace defective thermostat. If not OK, place jumper "ON"...
- Page 29 Symptom Possible Cause Corrective Action 8. Floating flames, A. Potentially dangerous A. Check the appliance input rate and reduce if necessary. lazy ill-defined, incomplete combustion due The air intake/exhaust flow system may be too restrictive or quiet flames, which to incorrect air to fuel ratio blocked (the rate at which the exhaust leaves [draft] roll around, (lack of combustion air or...
-
Page 30: Warranty Registration
Hearthstone Quality Home Heating Products, Inc. Warranty Department 317 Stafford Avenue Morrisville, VT 05661 NOTE: SENDING IN THE SIGNED WARRANTY REGISTRATION FORM IS NOT REQUIRED AS A CONDITION OF WARRANTY COVERAGE OR HEARTHSTONE’S PERFORMANCE. 07044-2...
Need help?
Do you have a question about the Champlain 8301 and is the answer not in the manual?
Questions and answers