MTU 12 V 4000 G23 Technical Documentation Manual page 177

Annex
8.4 Index
12/16 V 4000 Gx3 engine data: Continuous
operation, variable 3B, optimized exhaust
emission (EPA stage 2) . . . . . . . . . . . . . . . . . .
12V 4000 Gx3 engine data: Continuous
operation, variable 3B, optimized exhaust
emissions (TA-Luft) . . . . . . . . . . . . . . . . . . . . .
12V 4000 Gx3 engine data: Continuous
operation, variable 3B, optimized fuel
consumption . . . . . . . . . . . . . . . . . . . . . . . . . .
12V 4000 Gx3 engine data: Standby operation
3D, optimized fuel consumption
16V 4000 Gx3 engine data: Continuous
operation, variable 3B, optimized fuel
consumption . . . . . . . . . . . . . . . . . . . . . . . . . .
16V 4000 Gx3 engine data: Standby operation
3D, optimized fuel consumption
Abbreviations . . . . . . . . . . . . . . . . . . . . . . . . .
Accessories for Engine Governor (Electronic) /
Control System . . . . . . . . . . . . . . . . . . . . . . . .
ECU – Checking plug-in
connections . . . . . . . . . . . . . . . . . . . . .
ECU and connectors – Cleaning . . . . . .
After stopping the engine – engine remains
ready for operation . . . . . . . . . . . . . . . . . . . . .
After stopping the engine – putting the engine
out of service . . . . . . . . . . . . . . . . . . . . . . . . .
Air Filter . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Air filter – Check
Air filter removal and installation . . . . . .
Air filter replacement . . . . . . . . . . . . . . .
Rubber sleeves between air intake elbow
and turbocharger – Replacement
Air filter – Check . . . . . . . . . . . . . . . . . . . . . . .
Air filter removal and installation . . . . . . . . . . .
Air filter replacement . . . . . . . . . . . . . . . . . . . .
Air Intake . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Service indicator – Signal ring position
check . . . . . . . . . . . . . . . . . . . . . . . . . .
Air starter – manual operation . . . . . . . . . . . . .
Auxiliary materials, fire prevention and
environmental protection . . . . . . . . . . . . . . . . .
Battery-charging Generator
Battery-charging generator drive – Drive
belt replacement . . . . . . . . . . . . . . . . . .
Battery-charging generator drive – Drive
belt tension adjustment . . . . . . . . . . . . .
Battery-charging generator drive – Drive belt
replacement . . . . . . . . . . . . . . . . . . . . . . . . . .
M015710/01E 07-02
. . . . . . . . . . .
. . . . . . . . . . .
A
. . . . . . . . . . . . . . . . . .
. . . . .
B
. . . . . . . . . . . . . .
Battery-charging generator drive – Drive belt
tension adjustment
46
Belt Drive
Drive belt – Condition check . . . . . . . . .
51
Cabling, General for Engine / Gearbox /
Plant . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
36
Engine wiring – Check
Centrifugal oil filter – Cleaning and filter-sleeve
21
replacement
Charge-air coolant – Draining . . . . . . . . . . . . .
Charge-air coolant – Filling . . . . . . . . . . . . . . .
41
Charge-air coolant change
26
Charge-air coolant level check
Charge-air coolant pump – Relief bore
check . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Charge-air Cooling, General, Left Side . . . . . .
169
Intercooler – Checking condensate
drains for coolant discharge and
156
obstructions
Cooling Circuit, General, HT Circuit
157
Engine coolant – Change
156
Engine coolant – Draining . . . . . . . . . . .
Engine coolant – Filling . . . . . . . . . . . . .
62
Engine coolant – Sample extraction and
analysis . . . . . . . . . . . . . . . . . . . . . . . . .
63
Engine coolant level – Check
125 Engine coolant pump – Relief bore
126 check
127
Crankcase Breather
125
Crankcase breather – Oil separator
replacement, diaphragm check and
128
replacement
126
Crankcase breather – Oil separator replacement,
127 diaphragm check and replacement . . . . . . . . .
125 Cylinder head cover – Remove and install
129 Cylinder Liner
Cylinder liner – Endoscopic
129 examination
Instructions and comments on endoscopic
130
and visual examination of cylinder
liners . . . . . . . . . . . . . . . . . . . . . . . . . . .
11
Cylinder liner – Endoscopic examination
153
Drive belt – Condition check
154
153
ECU – Checking plug-in connections
ECU and connectors – Cleaning . . . . . . . . . . .
154
. . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . .
C
. . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . .
. . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . .
D
. . . . . . . . . . . . . .
E
173
153
152
152
155
155
137
149
147
146
150
151
124
124
. . . . . . . . 139
139
142
140
145
. . . . . . . . 143
144
102
102
102
. . . 108
98
98
100
. . . . 98
152
. . . . . . . 157
156
© MTU