Table Of Contents - Valor L1 1500KN Installation Manual

Welcome to Valor
This appliance has been professionally installed by:
Dealer Name: ________________________________
Phone:______________________________________
Fireplace Safety ................................................. 4
Specifi cations ..................................................... 6
Kits & Accessories .............................................. 7
Dimensions & Location ..................................... 8
Installation Planning ......................................... 9
Before Installing ............................................................9
Overview ......................................................................10
Mantel Clearances ......................................................11
Framing .........................................................................13
Wall Finish ....................................................................17
Material Specifications ..............................................17
Non-Combustible Cement Board ............................17
Avoiding Cracking Wall Finishes ...............................19
Venting .............................................................. 20
Overview ..................................................................... 20
Co-Axial ....................................................................... 21
Typical Co-axial Venting Components ....................21
Venting Chart ..............................................................22
Restrictor Settings .....................................................23
Horizontal Vent Termination ....................................24
Vertical Vent Termination .........................................25
Co-Linear Conversion ................................................ 26
Installation Into Existing Fireplace Cavity ..............26
Installation Partially Into Fireplace Cavity ..............27
Installation Into Existing Adjacent Chimney ..........28
Example of Co-linear Conversion Accessories ......29
Installation ....................................................... 30
Appliance Preparation .............................................. 30
Unpack Appliance ......................................................30
Fit Standoffs ................................................................30
Remove Heat Shield ...................................................30
Convert from Top to Rear Outlet (if required) .......31
Fit Appliance into Framing ........................................32
Remove Window ........................................................33
®
Please read this manual
installing and operating this
appliance.
HeatShift™ System-if used .................................... 34
Remove Convection Baffle ...................................... 34
Install HeatShift Take-Off Collars to Appliance .... 34
Electrical Wiring ......................................................... 35
Gas Supply ................................................................... 37
Liners ........................................................................... 39
Fuel Beds ..................................................................... 40
Birch Log Kit 1505BLKV2 .......................................... 40
Driftwood Kit 1505DWKV2 .......................................43
Decorative Glass Murano 1500DGM ..................... 46
Rocks & Shale Set 1514RSS .......................................47
Split Wood Kit 1505SWKV2 .......................................49
Window Re-Installation & Checking ....................... 52
Wall Switch .................................................................. 53
Remote Control Pairing ............................................. 55
Checking Operation and Aeration .......................... 57
Trim & Barrier Screen ................................................ 58
Wiring Diagram ................................................ 59
Approved Venting Components .................... 60
Commonwealth of Massachusetts ............... 62
Appendix A-Lighting Instructions ............... 64
Appendix B-Remote Control Operation .... 65
Appendix C-Wall Switch Operation ............ 72
Appendix D-HeatShift System .................... 73
Appendix E-Spare Parts ............................... 94
BEFORE
3