Storage; Transportation; Lifting - CardioQuip MCH-1000 Operators & Service Manual

Storage

If the MCH is to be stored for more than seven (7) days, ensure that the unit is drained and
cleaned per the Quarterly Maintenance Procedure listed under the Maintenance section.
The system can be safely stored after performing this procedure. The system and system
accessories shall be stored drained and dry (see System Drain and Tank Drain sections). The
MCH shall be stored in an environment where the temperature range is within 0°–43°C (32°–
100°F), and the relative humidity is less than 95%.

Transportation

The MCH should be transported in either the original carton, or an equivalent carton, to
prevent damage during shipment. If the unit has been in contact with blood, blood
components, or body fluids, it must be thoroughly cleaned and disinfected per the Quarterly
Maintenance Procedure before packing. The MCH should not be exposed to environmental
conditions outside of those listed in the Storage section.

Lifting

The MCH-1000(i) should be lifted by no fewer than 2 persons, and should be drained prior to
being lifted. Use proper lifting techniques to avoid injury. The lift points are located at each of
the four corners. The lifters' hands should be wrapped tightly around the wheelbase frame
projections at each corner. For short lifts (e.g., assisting the MCH over low obstacles such as
cords or thresholds ≥10mm), the convenience handles may be used with care. Facing the
MCH, with your back to the obstacle, grasp the handle with both hands, with an underhand
grasp, and lift upward on the handle while pulling the MCH toward you, over the obstacle.
CAUTION: Do not lift the MCH by the drain or water/hose connections. Lifting
by these connectors will cause equipment damage.
12 OVERVIEW | Storage