Subscribe to Our Youtube Channel
Related Manuals for Fisher Scientific 15-460-2Q
Summary of Contents for Fisher Scientific 15-460-2Q
- Page 1 Isotemp Fisher Scientific Isotemp Economy Water Baths Installation and Operation Manual 103412 (7002200) Rev. 5 © 2010 Fisher Scientific Inc. All rights reserved Printed in U.S.A.
- Page 2 Preface Models covered in this manual Catalog Number Model Number Specific Information Voltage 15-460-2Q (2228) 120V 15-460-3Q (2235) 230V 15-460-2SQ (2230) 120V 15-460-3SQ (2236) 230V 15-460-5Q (2239) 120V 15-460-6Q (2240) 230V 15-460-10Q (2223) 120V 15-460-11Q (2224) 230V 15-460-15Q (2226) 5L/10L, dual chamber...
- Page 3 Fisher Scientific makes no representations or warranties with respect to this manual. In no event shall Fisher Scientific be held liable for any damages, direct or incidental, arising out of or related to the use of this manual.
- Page 4 EU Member State European Country, and this product should be disposed of or recycled through them. Further information on Fisher Scientific’s compliance with this directive, the recyclers in your country and information on these products will be available at www.fishersci.com.
- Page 5 When more extensive service is necessary, we will assist you with direct factory trained technicians or a qualified service organization for on-the-spot repair. If your service need is covered by the Fisher Scientific Products warranty, we will arrange for the unit to be repaired at our expense and to your satisfaction.
-
Page 6: Table Of Contents
Schematic ...........8-1 Fisher Scientific... -
Page 8: Introduction
Introduction Section 1 Congratulations on the purchase of your new Fisher Scientific Isotemp Economy Water Bath. Isotemp Water Baths offer the versatility needed to handle virtually any clinical laboratory procedure - incubation, inactivation, agglutination - as well as most serological, pharmaceutical, biomedical, and industrial procedures. -
Page 10: Safety Information
Weak concentrations of hydrochloric acid, hydrofluoric acid, hydrobromic acid, hydroiodic acid, sulfuric acid, or chromic acid. Weak salt solutions containing sodium chloride, calcium chloride, chromate or chromium compounds. Most photographic solutions. High Purity water (deionized water >1M ohm) Fisher Scientific Isotemp Economy Water Bath... - Page 11 Always use the diffuser tray. • The thermometer contains kerosene and is not expected to be a health hazard in the normal intended use of the thermometer. Isotemp Economy Water Bath Fisher Scientific...
-
Page 12: Specifications
Specifications Section 3 These are nominal specifications. Fisher Scientific reserves the right to change specifications or designs at any time without incurring obligation. Temperature range ...... - Page 13 Section 3 Specifications Catalog Number Model Number Specific Information Voltage 15-460-2Q (2228) 120V 15-460-3Q (2235) 230V 15-460-2SQ (2230) 120V 15-460-3SQ (2236) 230V 15-460-5Q (2239) 120V 15-460-6Q (2240) 230V 15-460-10Q (2223) 120V 15-460-11Q (2224) 230V 15-460-15Q (2226) 5L/10L, dual chamber 120V...
-
Page 14: Unpacking And Installation
The water bath is shipped in a single carton. When unpacking the unit, check each loose item against the packing list below. Should a shortage exist, notify your Fisher Scientific distributor, identifying the part by name and catalog number. Note If there is shipping damage, keep entire shipment intact - retaining the carton and all packing material - and file a claim with the final carrier. -
Page 15: Assembly And Installation
3. Connect the line cord to a suitable grounded electrical outlet. Isotemp Economy Water Bath Fisher Scientific... -
Page 16: Filling The Unit
50K to 1M ohm will void the manufacturer warranty. If you should have any questions, please contact Technical Services. Note Deionized water is not recommended and may cause rusting and pitting in the reservoir. Fisher Scientific Isotemp Economy Water Bath... -
Page 17: Controls And Indicators
Note The water bath, full of water (within 1-1.5" of top of tank), with lid, is designed to reach 37°C in less than 60 minutes or 90°C in less than 180 minutes. Isotemp Economy Water Bath Fisher Scientific... -
Page 18: Operation
Note The safety control is not as accurate a control as digital control. Note The thermometer contains kerosene and is not expected to be a health hazard in the normal intended use of the thermometer. Fisher Scientific Isotemp Economy Water Bath... -
Page 19: Setting The Limit Control
Control up to call for a higher temperature (heater on, green lamp on). The amber lamp will turn on when the limit open turning off the heater. 5. Without adjusting the Limit Control, set the Temperature Control to the desired temperature below the limit control. Isotemp Economy Water Bath Fisher Scientific... -
Page 20: Emptying And Cleaning The Unit
Note If Alarm Light comes on during normal cycling, turn backup controller knob slightly clockwise and monitor. (If backup and digital controls overlap, the bath will have a wider temperature control band.) Fisher Scientific Isotemp Economy Water Bath... -
Page 22: Troubleshooting
Amber Limit Control Indicator on constantly defective Temperature Control. Check settings. Temperature F or C set in error; temperature not calibrated (perform calibration procedure Display not correct with thermometer); defective controller (call Technical Services). Fisher Scientific Isotemp Economy Water Bath... -
Page 24: Replacement Parts
1546233Q Cover, 5 liter Plastic Lid 107649 Stainless Steel Lid CVM1598X1 Cover, 10 liter Plastic Lid 102306 Stainless Steel Lid 1546234Q Cover, 20 and 28 liter Plastic Lid 102307 Stainless Steel Lid 1546235Q (continued) Fisher Scientific Isotemp Economy Water Bath... - Page 25 103414FS Diffuser Tray, 2 liter 103410 Diffuser Tray, 10 liter 102354 Diffuser Tray, 20 or 28 liter 102355 Fuse, Type 3AG 1.25x.25, 10 Amp 45920-DB Fuse, 5x20mm, F5A, 250V 102487 Power Switch (S1) 102627 Isotemp Economy Water Bath Fisher Scientific...
-
Page 26: Schematic
Schematic for 120V Units Schematic for 230V Units Fisher Scientific Isotemp Economy Water Bath... - Page 28 For customer service, call 1-800-766-7000 To fax an order, use 1-800-926-1166 To order online: www.fishersci.com...
Need help?
Do you have a question about the 15-460-2Q and is the answer not in the manual?
Questions and answers