Table of Contents
Advertisement
GENERAL
SAFETY
SERVICE RULES
MODEL IDENTIFICATION
SPECIFICATIONS
TORQUE VALUES
TOOLS
WIRING DIAGRAM
CABLE
&
HARNESS ROUTING
EMISSION CONTROL
SYSTEM
1.
GENERAL
INFORMATION
EMISSION CONTROL INFORMATION LABELS
1-1
1-1
1-2
1-3
1-5
1-
7
1-9
1-11
1-14
1-
15
GENERAL SAFETY
(4id;liliiitj
If
Ihe
engine
must
be running to do some work, moke
sure
the area ;s
well· ventilated. Nellf!r
run
the engine in a closed
area,
The
exhaust contains
poisonous
corbon
m
onoxtde gas.
h'i/.l@@'
The battery
electrolyle contains
sulfuric
acid.
Protect
your
eyes, skin and
clothing.
In
case
of contact, flush
thorough-
ly
with
worer
and
call
Q
doctor
if your eyes were exposed.
SERVICE RULES
Gasoline
is
extremely flommable
and
is explosive
under
cerrain conditions,
Do
not
smoke or
allow {/Qmes
or
sparks
in your working area.
'CI;i!i!ii1
The battery
generales
hydrogen
gas
whi
ch CfIn
be
highly
ex-
plasi,,€!.
Do
no
t
smoke or
allow
flames or sparks
near
the
battery. especially
while
charging
it.
1. Use
genuine
HONDA
or
HONDA·recommended parts and
lubricants
or their
equivalent.
Parts that do not meet HONDA's
design specifications may
damage the
motorcycle.
2. Use the special
tools
designed for this product.
3. Install new gaskets, O ....
ings,
cotter
pins,
lock plates, etc. when reassembling.
4
.
When tightening bolts or nuts, begin
with
the larger-diameter or
inner
bolts first, and tighten to the
specified
torque diago·
nally in
2-3 steps, unless a particular
sequence
is specified
.
5
.
Clean parts
in
non-flammable or high flash point solvent upon disassemb ly
.
Lubricate
any sliding
surfaces
before reassembly_
6. After reassembly. check all parts for proper installation and operation.
7. Use
only
metric tools when servicing this motorcycle.
Metric
bolts, nuts, and screws are not
interchangeable
with English
fasteners. The use
of
incorrect
tools and
fasteners may damage the motorcycle.
8.
Route
all f'lectrical wires as shown
on
page 1·11, Cable & Harness
Rout
ing,
and alway
s
away from sharp
edges
and areas
where they
might
be pinched
between
moving parts.
1-1
Hide quick links:
Advertisement
Table of Contents
