Taking Out Of Service And Storage; Safety Rules For Taking Out Of Service And Storage; Storage Conditions; Measures Before Taking Out Of Service - Kubota U17-3a Operating Instructions Manual

TAKING OUT OF SERVICE AND STORAGE

If the excavator is taken out of service for up to six months, the measures before, during and after taking out of
service must be carried out as described below. If the vehicle is to be taken out of service for a period of over
six months, contact the manufacturer for additional measures.

Safety rules for taking out of service and storage

The general safety rules (page 12), the safety rules for operation (page 43) and the safety rules for mainte-
nance (page 84) apply.
When taking the excavator out of service, secure it against unauthorised use.

Storage conditions

The storage place must have a sufficient bearing capacity for the weight of the excavator.
The storage place must be frost-free, dry and well ventilated.

Measures before taking out of service


Clean and dry the excavator thoroughly (page 89).

Check the hydraulic oil level, add oil if necessary (page 48).

Change the engine oil and oil filter (page 91).

Drive the excavator to the storage place.

Remove the battery (page 98) and store it in a dry and frost-free room. If necessary, connect it to a trickle
charger.

Grease the front attachments (page 49).

Grease the swivel bearing (page 99).

Grease the swivel gear (page 99).

Check the antifreeze strength of the coolant, add coolant if necessary (page 89).

Grease the hydraulic cylinder piston rods.

Measures during taking out of service


Charge the battery regularly (page 98).
108
Taking out of service and storage