Table Of Contents - Raypak TempTracker mod+ Installation And Operation Instructions Manual

2 Raypak, Inc.
teMptracker Mod+ layout . . . . . . 3
teMptracker Mod+ overvIeW . . . . 4
Reset Ratio/Outdoor Reset . . . . . . . . . . 5
Make Sure You Have the Right Control . . 6
InItIal setup . . . . . . . . . . . . . . . 6
Selecting the System Features. . . . . . . 6
InstallatIon . . . . . . . . . . . . . . . 7
Mounting the Enclosure . . . . . . . . . . 7
Install the Sensors . . . . . . . . . . . . . 8
Heating/Storage Tank System Sensor (HSS)
Installation . . . . . . . . . . . . . . . . . . . 8
Outdoor Sensor Installation . . . . . . . . . . 8
Wiring. . . . . . . . . . . . . . . . . . . . 9
Wiring the Power (Terminals 1, 2) . . . . . . . 9
Wiring the Sensors . . . . . . . . . . . . . . . 9
Wiring the Shutdown, Tstat, or Setback (Terminals
31, 32) . . . . . . . . . . . . . . . . . . . . . 9
Wiring the System Prove (Terminals 29, 30) 10
Wiring for Domestic Hot Water Priority (Terminals
29, 30) . . . . . . . . . . . . . . . . . . . . 10
Wiring the System Output (Terminals 3, 4). . 10
Wiring the Boilers . . . . . . . . . . . . . . 10
Wiring to Modulating Motors . . . . . . . . . 11
Connecting to the TempTracker mod+ Extension
Panels . . . . . . . . . . . . . . . . . . . . 11
Menu seQuence . . . . . . . . . . . . . 12
Startup Settings . . . . . . . . . . . . . . 14
Program Change Settings . . . . . . . . . . 14
Startup Sequence . . . . . . . . . . . . . . 14
Sensor Type . . . . . . . . . . . . . . . . . 14
EMS Input Mode . . . . . . . . . . . . . . . 14
(Available In Set point Only) . . . . . . . . . 14
Selecting the Output Type . . . . . . . . . . 14
Modulating Mode . . . . . . . . . . . . . . . 14
Prove/Domestic Hot Water (DHW) . . . . . . 15
Domestic Hot Water Set Point . . . . . . . . 15
Shutdown/Tstat/Setback Mode . . . . . . . . 15
contents
Boost Mode . . . . . . . . . . . . . . . . . 15
(Not Available with Setback) . . . . . . . . . 15
Sensor Fault . . . . . . . . . . . . . . . . . 16
Setting the Control to Factory Defaults. . . 16
Program Change Settings . . . . . . . . . . 17
Season . . . . . . . . . . . . . . . . . . . . 17
Set Point . . . . . . . . . . . . . . . . . . . 17
Reset Ratio. . . . . . . . . . . . . . . . . . 17
Outdoor Cutoff Temperature . . . . . . . . . 18
Offset . . . . . . . . . . . . . . . . . . . . . 18
Minimum Water Temp . . . . . . . . . . . . 18
Maximum Water Temp . . . . . . . . . . . . 18
System Settings . . . . . . . . . . . . . . 19
Gain . . . . . . . . . . . . . . . . . . . . . 19
Lead Boiler Rotation . . . . . . . . . . . . . 19
Purge Delay . . . . . . . . . . . . . . . . . 19
Lag Delay . . . . . . . . . . . . . . . . . . 20
Standby Time. . . . . . . . . . . . . . . . . 20
System Run-On . . . . . . . . . . . . . . . 20
Setback. . . . . . . . . . . . . . . . . . . . 20
Last Stage Hold . . . . . . . . . . . . . . . 21
Day/Night Schedules . . . . . . . . . . . . . 21
Set Time . . . . . . . . . . . . . . . . . . . 22
History . . . . . . . . . . . . . . . . . . . 22
Maintenance . . . . . . . . . . . . . . . . 23
System & Outdoor Sensor Trim . . . . . . . 23
Soft-Off Delay . . . . . . . . . . . . . . . . 23
Output Trim. . . . . . . . . . . . . . . . . . 23
Configuration . . . . . . . . . . . . . . . . . 24
Display . . . . . . . . . . . . . . . . . . . . 24
Boiler Stage Settings . . . . . . . . . . . . 25
Mode . . . . . . . . . . . . . . . . . . . . . 25
troublesHootInG . . . . . . . . . . . . 26
specIfIcatIons . . . . . . . . . . . . . . 32
TempTracker mod+ Specifications . . . . . 32
TempTracker mod+ Extension Specifications 32