Page 1
Operation, Installation & Maintenance Manual V V ertical Multista ertical Multistage Pumps ge Pump Pumps EVMSU Note: Models EVMSU/EVMSUL 1-20 and EVMUG/EVMUL 32-64 certified to NSF/ANSI 61 & 372. All specifications subject to change without notice. Certified to NSF/ANSI 61, ANNEX G...
(EVMSU 1, 3, 5, 10, 15 and 20 and EVMU 32, 45, 64 Do not connect pump to a power supply until m3/h), with varying number of stages available either as a permanently grounded.
8.1 COUPLING TO THE MOTOR due to possible force created at suctions The motors to be coupled to the EVMU and EVMSU pumps must b) Support and align pipes so that they do not put any stress meet NEMA standards. Consult motor nameplate and motor on the pump;...
Prolonged operation with the discharge pipe closed can of pump cavitation due to: cause damage;EVMU and EVMSU pumps are designed for – excessive difference in height or excessive pressure loss continuous and normal off/on operation. Rapid cycle may...
Check the liquid level “scrapped.” Completely empty the product of all fluids – do not leave any treated fluid inside it. EBARA pumps should not Restrict the Pressure too low (typically) contain hazardous polluting material. For further...
Page 12
(diame- pump FOR BRIEF ter of pipe, elbows PERIODS etc.) Thermal protection - Liquid temperature Contact the nearest intervention - Discharge line Internal fault authorized distributor or backpressure service center EBARA Pumps Americas Corporation rev. 01/19 www.pumpsebara.com...
Page 13
14 ADDITIONAL TECHNICAL INFORMATION 15.1 WARNINGS FOR CORRECT OPERATION OF EVMU 14.1 MAXIMUM WORKING PRESSURE CHART AND EVMSU PUMPS (FIG. 1 - FIG. 2) Pump model FIG. 1 Maximum working pressure (psi) EVMSU1 EVMSU3 EVMSU5 2-18 2-15 2-12 20-29 16-23...
Page 14
ASSEMBLING THE MOTOR TO THE PUMP - EVMSU1 to EVMSU20 [-A-] 360° M6=15 Nm M8=20 Nm M12=40 Nm M16=70 Nm EVMSU 3/8”=19.7 lb-ft 1/2”=43 lb-ft 5/8”=92 lb-ft EBARA Pumps Americas Corporation rev. 01/19 www.pumpsebara.com...
Page 15
ASSEMBLING THE MOTOR TO THE PUMP - EVMSU1 to EVMSU20 [-A-] M6=15 Nm (11 lb-ft) M8=18 Nm (13 lb-ft) M10=50 Nm (37 lb-ft) EVMSU EVMSU 3 Nm (2.2 lb-ft) EBARA Pumps Americas Corporation rev. 01/19 www.pumpsebara.com...
Page 41
Cast iron EN -GJL-200 Motor liner Cast iron EN -GJL-200 Coupling guard AISI304 n i l Pum p f lange
EBARA Pumps Americas Corporation rev. 01/19 www.pumpsebara.com...