Table of Contents
Advertisement
Tables
Figure 18.
Suggested Wiring For Three Phase Tandem Pumps
Figure 19.
Siphon Connection
Figure 20.
Siphon Ports
Figure 21.
Inserting Siphon Assembly Into Manifold ..............................................25
Figure 22.
Locating Discharge Port Plug For Line Leak Transducer
Figure 23.
Locating Pump Line Test Port
Figure 24.
Service Screw, Line Test Port, And Air Purge Screw Locations ...........29
Figure 25.
Tank Test Port On Manifold
Figure 26.
Extractable Lock-down Nuts
Figure 27.
UMP Bolts And Gasket
Figure 28.
Verifying Pigtail's Female Connector Is Seated Properly
Figure 29.
Locating Packer And Manifold O-rings
Figure 30.
Inserting Check Valve Assembly Into Manifold .....................................35
Figure 31.
Extractable lock-down Nuts
Figure 32.
Packer-To-Manifold Wiring Connectors
Figure 33.
Male Connector's Indexing Pin
Figure 34.
Male Connector Index Hole In Base Of Socket
Figure 35.
Placing Masking Tape Alignment Marker On Front Of Male Connector ..42
Figure 36.
Correct Depth Of Male Connector In Packer Socket
Figure 37.
Locating Female Connector Set Screw
Figure 38.
Locating Air Purge Screw
Figure 39.
Locating Air Purge Screw Hitch Pin
Figure 40.
Reorienting The Air Purge Screw's Hitch Pin
Figure 41.
Hitch Pin In Position To Install Air Purge Screw
Figure 42.
Installing Air Purge Screw Hitch Pin In The Retaining Position
Figure 43.
Pump Parts
Figure 44.
Siphon Cartridge Kit ..............................................................................51
Figure 45.
Check Valve Housing Kit
Figure 46.
Check Valve Kit
Figure 47.
Siphon Cartridge Kit ..............................................................................52
Figure 48.
Hardware/Seal Kit
Figure 49.
Electrical Connector Kit
Figure 50.
UMP Wire Termination And Sealing Kit
Figure 51.
Die Spring Kit
Figure 52.
Air Purge Screw Kit ...............................................................................56
Figure A-1.
Pump On condition
Figure A-2.
Relief valve vents excess line pressure
Figure A-3.
Locking down the check valve for line testing ..................................... A-2
Figure A-4.
Removal of check valve assembly for service
Figure A-5.
Returning the check valve to its normal operating position
Figure A-6.
Purging air from manifold .................................................................... A-4
Table 1.
Maximum Specific Gravity And Maximum Viscosity ..................................7
Table 2.
Distances From Top Of Lifting Screw To Inlet .........................................11
Table 3.
Electrical Service Information ..................................................................11
Table 4.
UMP Model Dimensions ..........................................................................12
Table 5.
Approximate Pump Shut Off Pressures ..................................................12
Table 6.
UMP And Packer/Manifold Combinations ...............................................13
Table 7.
International Pump Parts List ..................................................................50
Table 8.
Siphon Cartridge Kit Parts List ................................................................51
Table 9.
Check Valve Housing Kits Parts Lists .....................................................51
Table 10.
410153-001 Check Valve Kit Parts List ...................................................52
Table 11.
410153-002 Hi Pressure Check Valve Kit Parts List ...............................52
Table 12.
410486-001 Conduit Bushing Kit Part List ..............................................52
...............................................................................24
.........................................................................................25
..............................................................27
..................................................................30
.................................................................31
.........................................................................32
..................................................................37
.............................................................41
.....................................................................46
......................................................46
...........................................................................................49
......................................................................51
....................................................................................52
.................................................................................53
........................................................................54
........................................................................................55
............................................................................. A-1
v
Table of Contents
...........................23
.....................26
.....................32
.................................................33
................................................41
....................................42
............................43
................................................44
.......................................47
...................................47
............48
................................................55
.............................................. A-1
.................................... A-2
................ A-3
Advertisement
Table of Contents
