Summary of Contents for Backyard Discovery Atlas 2002142
Page 1
ATLAS 6 FOOT DECK MODEL # 2002142 Assembly Instructions Owner's Manual Warranty Manufacturer: Backyard Discovery 3001 North Rouse Pittsburg, KS 66762 1-800-345-1491 Register your new swing set on-line @ www.backyardadventures.com (you will also find any updates on assembly instructions and information to order replacement parts).
Page 2
Owner’s Manual Please Read This Before Starting Assembly MISSING A PART? CALL US BEFORE GOING BACK TO THE STORE Th e store where you made your purchase does not stock parts for this item. If you have assembly questions or you are missing or have damaged parts, please call 1-800-856-4445 you can also visit www.backyarddiscovery.com...
Page 3
All freight and labor charges will be the responsibility of the purchaser. Backyard Discovery, Inc. warrants that this product will be free from defect in materials and workmanship for a period of two (2) years from the original date of purchase. This two (2) year warranty covers all parts not mentioned in the above ten (10) year warranty.
Page 4
Owner’s Manual Operating Instructions and Safety Warnings WARNING: BURN HAZARD • Pay special attention to plastic and metal surfaces as they may be hot enough to cause burns. • Always check the temperature of the product before NOTE: letting your children play on it. •...
Page 5
Owner’s Manual Please Read This Before Starting Assembly Positioning Your Playcenter Suggested Playground Surfacing • Th e playcenter is designed to be installed on a level • Do not install home playground equipment over surface by an adult with an adult helper. Place concrete, asphalt, packed earth, grass, carpet, or any in a fl at area of your yard to minimize ground other hard surface.
Page 6
Owner’s Manual Please Read This Before Starting Assembly APPENDIX A The following information is from the United States X3.1.3.2 Do not install loose-fi ll surfacing over hard surfaces such as concrete or asphalt. Consumer Product Safety Commission’s Information X3.1.4 Poured-In-Place Surfaces or Pre-Manufactured Sheet for playground surfacing material;...
Page 7
• Check all moving parts including swing seats, Backyard Discovery assumes no responsibility or ropes, cables, and chains for wear, rust, or other liability for any charge incurred by the Customer for deterioration.
Page 8
About Our Wood Backyard Discovery uses 100% Cedar (C. Lanceolata) wood. Although we take great care in selecting the best quality lumber available, wood is still a product of nature and susceptible to weathering which can change the appearance of your set.
Page 9
Tools Required for Installation: (These are the tools that are generally required for assembly of our outdoor products. These tools are not included with the outdoor product purchase.) (Level 24") (Jig Saw) (Square) (Phillips Screw Driver) (Open End Wrenches 1/2") (Tape Measure) (Claw Hammer) (Rubber Mallet - Optional)
Page 10
Basic Setup Dimensions Place the set on level ground, not less than 6 feet from any structure or obstruction such as a fence, garage, house, overhanging branches, laundry lines or electrical wires. Recommended Play Area SAFE PLAY ZONE 8'-4" 12'-6" 16'-8 7/8"...
Page 35
LAG SCREW (2) GRAB HANDLES (1) LADDER ASSEMBLY 5/16x2-1/2 WZ WASHER FORT ASSEMBLY NYLON 10x20 STEP 20 WASHER FLAT 5/16 WZ WASHER LOCK INT 8x15 WZ WASHER SAFETY CONE 9x28 WZ LAG SCREW HEX 5/16x2 WZ (4 PLCS) Pre-drill WASHER LOCK INT 8x15 WZ 3/16"...
Page 36
AND / (3-7) WALL PANEL -PICKET - 1WPSL-17 (3-7) WALL PANEL -SOLID - 1WPSO-17 FORT ASSEMBLY STEP 21 NOTE: PANEL HARDWARE INCLUDED WITH EACH PANEL. EXTERIOR VIEW...
Page 37
ATLAS SWING BEAMS Assembly Instructions Owner's Manual & Warranty Information are in the main fort Instructions and on our website @ www.backyarddiscovery.com Manufacturer: Backyard Discovery 3001 North Rouse Pittsburg, KS 66762 1-800-345-1491 Register your new swing set on-line @ www.backyarddiscovery.com (you will...
Page 38
Basic Setup Dimensions Place the set on level ground, not less than 6 feet from any structure or obstruction such as a fence, garage, house, overhanging branches, laundry lines or electrical wires. Adventure Olympian Titan Recommended Play Area with Fort 7' Deck 5' Deck 6' Deck...
Page 39
Parts Identification Wood Components SP7 - TH SB MED GUSSET - 4L3297-17 3 3/8"x3 3/8"x16 7/8" (86x86x430) SP9 - TH SB SM GUSSET - 4L3491-17 3 3/8"x3 3/8"x12" (86x86x305) SP10 - TH SB LG GUSSET - 4L3492-17 3 3/8"x3 3/8"x28" (86x86x711) SP11 - SB LEG SUPPORT - 4L1822-17 3 3/8"x3 3/8"x83"...
Page 45
TOP PLATE - OPTIONAL * * * SEE PARTS ID * * * SWING BEAM - SWING HANGER - LARGE * * * SEE PARTS ID * * * (DUCTILE) - 6HASH WASHER FLAT 5/16 WZ STEP 2 IF INSTALLING TOP PLATE AND STRIPS SEE INS-TOP PLATE &...
Page 51
TOP PLATE * * * SEE SWING BEAM PARTS ID * * * SWING BEAM - SWING HANGER - LARGE * * * SEE SWING BEAM PARTS ID * * * (DUCTILE) - 6HASH STEP 1 WASHER HARDWARE TABLE FLAT 5/16 WZ 4 POS 2 POS 3 POS...
Page 52
3H1290-17 METAL STRIP * * * SEE SWING BEAM PARTS ID * * * HARDWARE QTY: 2 POS = 8 EACH STEP 2 3 POS = 10 EACH 4 POS = 10 EACH METAL STRIP LAG SCREW HEX 5/16x1 1/2 WZ WASHER LOCK INT 8x15 WZ WASHER FLAT 5/16 WZ WASHER NYLON 10x20...
Page 53
- REBAR STAKES - 4M040 LAG SCREW HEX 5/16x2 WZ STEP 8 WASHER LOCK INT TAP GROUND STAKES AT APPROXIMATE 45° ANGLE AS SHOWN. 8x15 WZ STAKES CAN BE PLACED ON SWING SIDE OF 'A1'. WASHER LAG SCREW HEX 5/16x2 WZ FLAT 5/16 WZ (2 PLCS) WASHER LOCK INT 8x15 WZ...
Page 54
1TZG36-16 STANDARD TRAPEZE ASSEMBLY 1TZG47-16 SUPER TRAPEZE ASSEMBLY 1TZG58-16 TURBO TRAPEZE ASSEMBLY 1SSG63-16 STANDARD SWING SEAT ASSEMBLY 1SSG75-16 SUPER SWING SEAT ASSEMBLY 1SSG86-16 TURBO SWING SEAT ASSEMBLY STEP 9 * * * SEE YOUR DEALER FOR OPTIONS * * * &...