Table of Contents
Advertisement
Combilift Ltd
4.9:
Water Pump V- Belt
The engine is kept cool via the coolant that is pumped round the cooling
system. The water pump is powered by the Water pump V-belt. This is
checked as follows:
Check the belt tension. Perform this when the engine IS NOT running. Press
on the belt with a stick or rod. Ensure that the deflection is no more that 10mm
to 12mm. If it is adjust the belt via the pulley adjusting bolts
Check the belt condition: Inspect the condition of the belt. Be on the lookout
for signs of damage and wear. If the belt is damaged replace it immediately.
Also check if the belt has sunk deeply into the pulley as this indicates
excessive wear. Again replace the belt immediately if this is the case.
4.10: Fuel Filter – diesel engine trucks (Service interval = 500 Hours)
On all diesel engine Combilifts, there are two fuel filters located on the rear of
the fuel tank. The first filter, the small plastic filter, is to prevent particles
entering the electric fuel pump. The second larger filter is to prevent any
remaining particles entering the engine. These must be replaced in
accordance with the maintenance chart. They are both accessed by entering
the frame of the machine.
4.11: Air Filter Element (Service Interval = 500 Hours)
The air filter housing is located on top of the bonnet on the right hand side of
the machine. The air filter cartridge must be replaced at intervals of every 500
hours (or 8 months depending on which occurs first). Always ensure that the
Dust Valve is pointing down.
In order to change the air filter Cartridge, take the following steps:
1. Remove the end cap from the filter housing
2. Remove the existing air filter cartridge and replace with the new
3. Replace the End cap of the housing ensuring that the Dust valve
C2500CB-OM-EN-11
cartridge. Only use a genuine Combilift component.
is pointing downwards as shown.
C2500-C3000CB O&S Manual
4-12
Hide quick links:
Advertisement
Table of Contents
