Table Of Contents - Grundfos SCALA Installation And Operating Instructions Manual

English (GB) Installation and operating instructions
Original installation and operating instructions
These installation and operating instructions
describe Grundfos SCALA domestic water supply
pumps.
Sections 1-4 give the information necessary yo be
able to unpack, install and start up the product in a
safe way.
Sections 5-14 give important information about the
product, as well as information on service, fault
finding and disposal of the product.
CONTENTS
1. General information
1.1 Target group
1.2 Symbols used in this document
2. Receiving the product
2.1 Inspecting the product
2.2 Scope of delivery
3. Installing the product
3.1 Location
3.2 System sizing
3.3 Mechanical installation
3.4 Foundation
3.5 Installation examples
3.6 Suction pipe length
3.7 Electrical connection
4. Starting up the product
4.1 Priming the pump
4.2 Starting the pump
4.3 Shaft seal run-in
5. Storing and handling the product
5.1 Handling
5.2 Storing
5.3 Winterizing
6. Product introduction
6.1 Product description
6.2 Application
6.3 Pumped liquids
6.4 Identification
7. Control functions
7.1 Menu overview, SCALA2
8. Operating the controller
8.1 Setting the outlet pressure
8.2 Locking and unlocking the operating
panel
8.3 Expert settings, SCALA2
8.4 Resetting to factory settings
9. Starting up the product after shutdown
or standstill
9.1 Deblocking the pump
9.2 Controller settings
9.3 Priming
10. Servicing the product
10.1 Maintaining the product
10.2 Customer service information
10.3 Service kits
11. Taking out of operation
12. Fault finding the product
12.1 Grundfos Eye operating indications
12.2 Fault resetting
12.3 Fault finding chart
13. Technical data
13.1 Operating conditions
Page
13.2 Mechanical data
13.3 Electrical data
4
4
14. Disposal
4
4
Warning
4
Prior to installation, read this document
4
and the quick guide. Installation and
operation must comply with local
4
regulations and accepted codes of good
4
practice.
4
4
Warning
5
This product can be used by children of
6
eight years and up and persons with
7
reduced physical, sensory or mental
8 capabilities or lack of experience and
knowledge if they are under supervision or
8
have been instructed in the safe use of the
8
product and understand the hazards
8
involved.
8
Children must not play with the product.
9
Cleaning and maintenance of the product
9
must not be made by children without
supervision.
9
9
This pump has been evaluated for use with
9
water only.
9
9
Warning
9
Risk of electric shock.
10
This pump has a grounding conductor and
12
grounding-type attachment plug. To reduce
12 the risk of electric shock, be certain that
the pump is connected only to a properly
13
grounded, grounding-type receptacle.
13
13
13
15
15
15
15
15
15
15
16
16
16
17
17
17
18
21
21
21
21
21
3