Dangers From The Battery - Fronius ActiveCharger 1000 Operating Instructions Manual

If necessary, provide an adequate earthing connection for the workpiece.
Switch off unused devices.
Dangers from the
The substances contained in the battery used in this device can be harmful to the environ-
battery
ment and to human and animal health.
If the device becomes damaged, please observe the following points:
-
-
Under improper conditions fluids can escape from the battery. Liquid may leak out the bat-
tery if the battery is misused.
-
-
-
-
The battery can catch fire if overheated. Do not expose the device to heat
(e.g. a permanent heat source or fire)
If the battery is damaged or subjected to improper use, dangerous vapours may be given
off which can irritate the airways.
If this happens:
-
-
With a faulty battery, liquid may leak out of the device.
-
-
-
Do not operate or store the device in a potentially explosive atmosphere.
Special regulations apply in rooms at risk of fire or explosion.
Observe relevant national and international regulations.
To comply with European Directive 2006/66/EC on batteries and rechargeable batteries
and its implementation in national law, batteries and rechargeable batteries that have
reached the end of their life must be collected separately and returned to an approved re-
cycling facility. Be sure to return any device that you no longer require to your dealer or find
out about the approved collection and recycling facilities in your area. Ignoring this Euro-
pean Directive may have potentially adverse effects on the environment and on your
health!
Devices with mechanically undamaged rechargeable batteries may be returned to the rel-
evant Fronius Service Partner for repair or replacement.
As soon as it becomes evident that the rechargeable battery has been mechanically dam-
aged (e.g. electrolyte is escaping), dispose of the device at your nearest recycling centre
in accordance with national laws and guidelines.
If anything is unclear or you have any questions about disposal, contact your Fronius Ser-
vice Partner.
Only charge the power source using the "C 53 battery charger". Risk of fire when using a
different battery charger.
Only operate the power source using the provided battery. Risk of injury or fire when using
a different battery.
If the battery is disconnected, keep it away from metal objects such as paperclips, coins,
keys, nails, screws or other small metal objects that could establish a connection between
the battery terminals. A short circuit of the battery pole can result in injury or fire.
14
Make sure that leaking fluids cannot get into the soil or groundwater
If pollution has already occurred, it must be removed in accordance with relevant na-
tional regulations
The liquid can cause irritation or burns.
Avoid contact with the liquid.
Should contact be made accidentally, immediately rinse the affected area with water.
In case of contact with eyes, seek medical attention.
Ensure an adequate supply of fresh air
Seek medical attention in case of discomfort
Avoid contact with the liquid
Hand the device over to a Fronius Service Partner for repair
Clean and check any parts that have come into contact with the liquid