System - Club Car Villager 2001 Owner's Manual

CAUTION
• BATTERIES IN A LOW STATE OF CHARGE WILL FREEZE AT LOW TEMPERATURES.
CLOSED (OFF) POSITION
(SELECTOR IS ALIGNED
WITH OFF MARKINGS ON THE SIDES OF VALVE)
OFF
VIEWED FROM SELECTOR
SIDE OF VALVE
Figure 14 Fuel Shut-off Valve – Closed Position
3. Drain carburetor and seal the fuel tank.
3.1. Place the Forward/Reverse handle in the NEUTRAL position and the neutral lockout cam in the
SERVICE position. Turn the fuel shut-off valve to the closed (OFF) position and run the engine
until fuel remaining in the carburetor and fuel lines is used up and the engine stalls. Return the
neutral lockout cam to the OPERATE position.
3.2. Loosen (do not remove) the carburetor drain screw and drain fuel remaining in bowl into a small
container, then pour the fuel from the container into vehicle fuel tank. Tighten carburetor drain
screw.
3.3. Disconnect fuel vent line from fuel tank vent nipple.
3.4. Plug fuel tank vent nipple so it is air tight. Club Car recommends using a slip-on vinyl cap.
4. To protect the engine, remove the spark plug and pour 1/2 ounce SAE 10 weight oil into the engine
through the spark plug hole. Rotate the engine crank shaft several times and then reinstall the spark
plug.
5. Inflate tires to rated capacities. See Tire Capacities, Page 32.
6. Grease front suspension and do all other semiannual periodic lubrication. See Periodic Lubrication
Schedule, Page 31.
7. Thoroughly clean front body, rear body, seats, cargo bed (four-passenger TransPorter only), engine
compartment, and underside of vehicle.
8. Do not latch the park brake. Chock wheels to prevent the vehicle from rolling.
TO RETURN THE STORED VEHICLE TO SERVICE
1. Restore fuel system to operation.
OFF
VIEWED FROM SELECTOR
Figure 15 Fuel Shut-off Valve – Open Position
2001 Transportation Gasoline Vehicle Owner's Manual
FULL OPEN (ON)
POSITION
SIDE OF VALVE
Storage
27