Section 11 - Troubleshooting And Electrical System; General Information; Troubleshooting Guide - Club Car FE 350 Maintenance And Service Supplement

SECTION 11 — TROUBLESHOOTING AND ELECTRICAL SYSTEM
DANGER
• See General Warning on page 10-1.
WARNING
• See General Warning on page 10-1.

GENERAL INFORMATION

This section contains the information required to correctly troubleshoot the vehicle. A troubleshooting guide is provided
for general troubleshooting.
In addition to troubleshooting, this section contains general information on the electrical system and the circuits
of the electrical system.

TROUBLESHOOTING GUIDE

The following troubleshooting guide will be helpful in identifying operating difficulties should they occur. The guide
includes the symptom, probable cause(s) and suggested checks. The procedures used in making these checks can be
found in the referenced sections of the maintenance and service manual.
TROUBLESHOOTING GUIDE
SYMPTOM
Engine does not start easily.
TABLE CONTINUED ON NEXT PAGE
POSSIBLE CAUSES
Spark plug is partially fouled or in poor
condition
Spark plug wire is damaged or loose
Loose wire connection at ignition coil or RPM
limiter
Intermittent ignition coil failure
Low cylinder compression
Water or dirt in the fuel system and/or
carburetor; dirty or clogged fuel filter
Carburetor improperly adjusted
Starter/generator belt is slipping
2009 FE 350 Maintenance and Service Supplement
CORRECTIVE ACTION
Section 13 — S10 FE 350 Engine
Section 14 — S27 FE 350 Engine
Section 13 — S10 FE 350 Engine
Section 14 — S27 FE 350 Engine
Test Procedures 14 – Ignition Spark, 15 – RPM
Limiter, and 16 – Ignition Coil
Test Procedures 14 – Ignition Spark, 15 – RPM
Limiter, and 16 – Ignition Coil
Section 13 — S10 FE 350 Engine
Section 14 — S27 FE 350 Engine
Section 15 — S10 FE350 Fuel System
Section 16 — S27 FE 350 Fuel System
Section 15 — S10 FE350 Fuel System
Section 16 — S27 FE 350 Fuel System
Belt Tension Adjustment on page 12-12
11
Page 11-1