Air Intake System - Club Car Carryall 294D Owner's Manual

AIR INTAKE SYSTEM

CAUT ION
• Do not drill into the driver-side frame. Failure to heed this caution could damage the engine by
allowing excessive contamination to enter the air intake system.
AIR FILTER REPLACEMENT
The air filter should be inspected periodically and replaced when necessary. Filter changes should not exceed
the recommended interval. See Periodic Service Schedule on page 34. More frequent service may be
required in extremely dirty operating environments. In the event of a loss of power, sluggish acceleration, or
a roughly running engine, service the air filter immediately.
Air Filter Removal
1. Release both canister tab lock (Figure 33).
2. Pull the canister cap away from the canister.
3. Remove the air filter cartridge (1). See following NOTE.
NOTE: The air filter cartridge is specifically designed for this engine. It only fits into the canister one way.
Use only the Club Car part (CCI P/N 102498601) designed for this engine.
1
Figure 33 Air Filter Cartridge
Air Filter Installation
1. Push the new air filter cartridge onto the inside canister nozzle.
2. Place the canister cap, marked TOP, on the top center of the canister.
3. Secure the canister cap with both tab locks.
4. Push the yellow tab lock in to secure canister cap.
Page 46 2006 Carryall 294/294 SE Gasoline and Diesel Vehicle Owner's Manual
Air Intake System