Fueling Instructions - Club Car Villager 2001 Owner's Manual

TO CARBURETOR
VENT TUBES
Figure 20 Gasoline Tank

FUELING INSTRUCTIONS

Read DANGER and WARNING on Page 8.
DANGER
• TURN KEY SWITCH TO OFF BEFORE FUELING.
• NEVER POUR GASOLINE INTO FUEL TANK WHEN ENGINE IS HOT OR WHILE IT IS RUNNING.
• TO AVOID ELECTRIC ARC CAUSED BY STATIC ELECTRICITY, THE FUEL STORAGE/
PUMPING DEVICE MUST BE GROUNDED. IF THE PUMP IS NOT GROUNDED, THE VEHICLE
MUST BE GROUNDED TO THE PUMP BEFORE AND DURING THE FUELING OPERATION.
• IF THE VEHICLE HAS AN ALL-WEATHER ENCLOSURE INSTALLED, THE GAS TANK
MUST BE PROPERLY VENTED AS SHOWN (FIGURE 20, PAGE 33).
• TO AVOID THE POSSIBILITY OF FIRE, BE SURE TO CLEAN UP ANY SPILLED GASOLINE
BEFORE OPERATING THE VEHICLE.
CAUTION
• TO ALLOW FOR EXPANSION, DO NOT FILL HIGHER THAN ONE INCH FROM TOP OF THE FUEL
TANK. AVOID SPILLING FUEL.
NOTE
• WHENEVER POSSIBLE, AVOID USING OXYGENATED FUELS AND FUELS THAT ARE
BLENDED WITH ALCOHOL. VEHICLES TO BE STORED FOR EXTENDED PERIODS SHOULD BE
PREPARED FOR STORAGE AS INSTRUCTED ON PAGE 26 OF THIS MANUAL.
Four-Passenger Villager:
1. Lift and remove the driver seat bottom. Proceed to Step 2.
TransPorter and Six and Eight-Passenger Villager:
1. Lift and remove the second forward-facing seat.
2. The fuel tank is located on passenger side of vehicle. Remove fuel cap and fill the fuel tank with fresh
unleaded gasoline only. See preceding CAUTION and NOTE.
3. Replace fuel cap on tank. Make sure cap is securely tightened.
4. Replace seat bottom.
VENT FUEL
SHUT-OFF
VALVE
GAS TANK
2001 Transportation Gasoline Vehicle Owner's Manual
Fueling Instructions
33