Daily Maintenance - TurboChef Eco Service Manual

Daily Maintenance

Follow the steps below when cleaning your Eco
oven. Use only TurboChef ®-approved cleaning
chemicals. The use of any other cleaning products
may damage critical oven components, resulting in
a non-warranty service call.
Step 1: Prepare the Oven
• Turn off the oven by touching the Off icon.
• Slightly open the oven door.
Step 1
• Cooling takes approximately 30 minutes. do not clean the oven until the oven
displays "ready to clean."
Step 2: Remove the Wire Rack and Lower Jetplate
• Lift the rear of the rack up and slide it upward to the back of the oven to remove
(Fig. A).
Step 2 (Fig A)
• Loosen the bottom jetplate thumbscrew.
• Lift the front of the bottom jetplate and pull it out from the cavity (Fig. B).
Step 3: Clean the Wire Rack and Lower Jetplate
Step 2 (Fig B)
• Wash, rinse, sanitize, and dry the rack and jetplate.
Step 4: Clean the Air Filter
• Remove the air filter from the back of the oven.
Step 4
• Rinse the air filter with hot water.
• Allow the air filter to dry completely.
Step 5: Wipe the Oven Interior
• Use a food vacuum or damp towel to remove large particles from the oven cavity.
Step 5
Step 6: Clean the Oven Interior
• Spray TurboChef Oven Cleaner onto the top, bottom, and sides of oven interior.
Step 6
WARNING: The oven operates at approximately 500°F (260°C) and may
cause injury if not allowed to cool properly.
WARNING: Be sure the oven interior is cool before removing these items.
CAUTION: DO NOT remove the top glass jetplate; breakage will result in
a non-warranty service call.
CAUTION: TurboChef does not recognize blocked air vents as a warrantable
claim. The filter must be cleaned regularly or replaced if damaged. During oven
operation, the filter must remain in place at all times.
CAUTION: DO NOT operate the oven without the air filter in place.
CAUTION: DO NOT spray Oven Cleaner into the holes on the back oven wall.
Doing so can damage critical oven components, resulting in a non-warranty
service call.
Supplies and Equipment
TurboChef ® Oven Cleaner (Product Number:
103180), TurboChef ® Oven Guard (Product
Number: 103181), nylon scrub pad, cleaning towel,
disposable gloves, protective eyewear, dust mask
(optional).
5