Page 1
WWW.CONCESSIONSTANDS.COM Instruction Manual Nacho Cheese Dispenser and Warmer Model No. 5300, 5300EX 10700 Medallion Drive, Cincinnati, Ohio 45241-4807 USA Part No. 36060 SPECIFICATIONS SUBJECT TO CHANGE WITHOUT NOTICE...
Failure to wire properly will void the warranty and may result in damage to the machine. It is Gold Medal Products Company’s recommendation that this machine be plugged directly into a wall outlet. The use of extension cords is not recommended due to safety concerns, and may cause sacrificed and/or reduced performance.
Page 4
Nacho Cheese WWW.CONCESSIONSTANDS.COM Dispenser and Warmer Model No. 5300, 5300EX OPERATING INSTRUCTIONS Controls and Their Functions YELLOW BUTTON - Factory set to dispense product for 8 seconds. RED BUTTON - Factory set to dispense product for 4 seconds. ORANGE BUTTON - Factory set to dispense product manually.
Step 2: Install a new tube. Make sure that the tube is securely seated into the new bag. Tube is included with Gold Medal Cheese Bags. To order tube separately use Item No. 5285. Step 3: Open the front door of the warmer.
Page 6
Nacho Cheese WWW.CONCESSIONSTANDS.COM Dispenser and Warmer Model No. 5300, 5300EX Installing and Removing Food Product (continued) Step 4: Place the product on the rack with the spout and tube directed toward the front, and downward through the opening. Step 5: Guide the tube through the pump slot from top to bottom.
Page 7
Nacho Cheese WWW.CONCESSIONSTANDS.COM Dispenser and Warmer Model No. 5300, 5300EX INITIAL SETUP FOR PORTION CONTROL Dispensing Volume The dispenser/warmer is set at the factory with pre-set dispensing volume levels (manual, small and large). • The Orange Switch is set to free-flow (manual), as long as button is activated the warmer will dispense product.
Page 8
Nacho Cheese WWW.CONCESSIONSTANDS.COM Dispenser and Warmer Model No. 5300, 5300EX MASTER BOARD SETTINGS Large Portion Small Portion (Dip Switch Bank for (Dip Switch Bank for Yellow Button Control) Red Button Control) Manual Portion (Dip Switch Bank for Orange Button Control) To Change Dispensing Settings Chili/Cheese Dispenser has three buttons for dispensing pre-set amounts of product.
Page 9
Nacho Cheese WWW.CONCESSIONSTANDS.COM Dispenser and Warmer Model No. 5300, 5300EX 6. Set the desired time for any button following the chart below: Switch Number Dispense Time ½ Second 1 Second 2 Seconds 4 Seconds 8 Seconds 16 Seconds 7 (Yellow Only)
Nacho Cheese WWW.CONCESSIONSTANDS.COM Dispenser and Warmer Model No. 5300, 5300EX TROUBLESHOOTING Nothing is Working ELECTRICAL FAILURE - Check that the plug is securely in outlet. Check outlet for power. Check Circuit Breakers. Door Will Not Close CLAMP OPEN – Close Clamp.
Nacho Cheese WWW.CONCESSIONSTANDS.COM Dispenser and Warmer Model No. 5300, 5300EX CARE AND CLEANING DANGER Machine must be properly grounded to prevent electrical shock to personnel. DO NOT immerse in water. Always unplug the equipment before cleaning or servicing. Good sanitation practice demands that all food preparation equipment be cleaned regularly. A clean looking, well-kept machine is one of the best ways of advertising your product.
Nacho Cheese WWW.CONCESSIONSTANDS.COM Dispenser and Warmer Model No. 5300, 5300EX MAINTENANCE INSTRUCTIONS DANGER Improper installation, adjustment, alteration, service, or maintenance can cause property damage, injury or death. Read the installation, Operating, and Maintenance Instructions thoroughly before installing or servicing this equipment.
Nacho Cheese WWW.CONCESSIONSTANDS.COM Dispenser and Warmer Model No. 5300, 5300EX ORDERING SPARE PARTS 1. Identify the needed part by checking it against the photos, illustrations, and/or parts list. 2. When ordering, please include part number, part name, and quantity needed.
Page 14
Nacho Cheese WWW.CONCESSIONSTANDS.COM Dispenser and Warmer Model No. 5300, 5300EX Cabinet – Front/Interior View Part Number Item Part Description Qty. 5300 5300EX CHEESE BAG TRAY EN0008 EN0008 CHEESE BAG SUPPORT 36027 36027 SWITCH MOUNT PANEL 36029 36029 DOOR MAGNET 36042...
Page 15
Nacho Cheese WWW.CONCESSIONSTANDS.COM Dispenser and Warmer Model No. 5300, 5300EX Pump – Detailed View 4, 5 Part Number Item Part Description Qty. 5300 5300EX SLIDING PUMP BLOCK 36031 36031 PUMP CAM LOCK 36032 36032 CAM M5 SLOTTED SCREW 77125 77125...
Page 16
Nacho Cheese WWW.CONCESSIONSTANDS.COM Dispenser and Warmer Model No. 5300, 5300EX Cabinet – Back/Interior View Thermometer located on the upper left side of the warmer. 8*, 9* * Export Model 5300EX uses IEC Power Cord and IEC Snap In Receptacle Part Number...
Nacho Cheese WWW.CONCESSIONSTANDS.COM Dispenser and Warmer Model No. 5300, 5300EX WIRING DIAGRAM Model No. 5300, 5300EX gmpopcorn.com Page 17 SPECIFICATIONS SUBJECT TO CHANGE WITHOUT NOTICE...
Need help?
Do you have a question about the 5300 and is the answer not in the manual?
Questions and answers