Installation; Horizontal Electric Actuation Trim Exploded View - Tyco DV-5 Manual

TFP1320
Page 10 of 14
NO. DESCRIPTION
1 300 psi/ 2000 kPa Water Pressure Gauge
2 1/4" Gauge Test Valve . . . . . . . . . . . . . . . . .
3 Model MC-1 Manual Control Station . . . . . .
4 Model AD-1 Automatic Drain Valve . . . . . . .
5 Model ASV-1 Automatic Shut-Off Valve
6 Item No. Not Used
7 1/2" Ball Valve . . . . . . . . . . . . . . . . . . . . . . .
8 1/2" Spring Loaded Check Valve . . . . . . . . .
9 1/2" Y-Strainer . . . . . . . . . . . . . . . . . . . . . . .
33
33
7
1
21
2
19
2" (DN50)
GROOVE x GROOVE
DV-5 DELUGE VALVE
31
31 SHOWN
39
23
21
36
27
35
7
LOCATION
38
FOR OPTIONAL
ELECTRICALLY
SUPERVISED
N.O. ALARM
24
CONTROL
43
VALVE
20
29
35
A1
(ORDERED
SEPARATELY)
11

Installation

General Instructions
Proper operation of the DV-5 Deluge
Valves depends upon their trim being
installed in accordance with the in-
structions given in this Technical Data
Sheet. Failure to follow the appropri-
ate trim diagram may prevent the DV-5
Valve from functioning properly, as well
as void listings, approvals, and the
manufacturer's warranties.
The DV-5 Valve must be installed in a
readily visible and accessible location.
The DV-5 Valve, associated trim, and
wet pilot lines must be maintained at
a minimum temperature of 40°F (4°C).
QTY. P/N NO. DESCRIPTION
. . 2 92-343-1-005 10 3/4" Swing Check Valve
1 46-005-1-002 11 3/4" Angle Valve
1 52-289-2-001 12 Drip Funnel Connector
1 52-793-2-004 13 Drip Funnel Bracket
. . . 1 92-343-1-021 14 Drip Funnel
15 3/32" Vent Fitting
2 46-050-1-004 16 1/4" x 18" Tubing
1 92-322-1-002 17 1/2" Tubing Connector
1 52-353-1-005 18 1/2" x 12" Tubing
33
33
5
24
9
8
32
34
24
33
21
33
35
33
29
22
10
42
27
42
15
(GREEN
44
TINT)
16
22
42
42
28
25
42
1-1/2 AND 2 INCH (DN40 AND DN50) DV-5 DELUGE VALVES
EXPLODED VIEW OF HORIZONTAL ELECTRIC ACTUATION TRIM
Heat tracing of the DV-5 Valve or its
associated trim is not permitted. Heat
tracing can result in the formation of
hardened mineral deposits that are ca-
pable of preventing proper operation.
The DV-5 Deluge Valve is to be in-
stalled in accordance with the follow-
ing criteria:
Step 1. All nipples, fittings, and de-
vices must be clean and free of scale
and burrs before installation. Use pipe
thread sealant sparingly on male pipe
threads only.
Step 2. The DV-5 Valve must be
trimmed in accordance with Figure
3A/3B or 5.
Step 3. Care must be taken to ensure
that check valves, strainers, globe
valves, etc. are installed with the flow
arrows in the proper direction.
QTY. P/N
. . . . . . . . . . . . . . . . 1 46-049-1-005
. . . . . . . . . . . . . . . . . . . . . . 2 46-048-1-005
. . . . . . . . . . . . . . . . .
1 92-211-1-005
. . . . . . . . . . . . . . . . . . . 1 92-211-1-003
. . . . . . . . . . . . . . . . . . . . . . . . . . 1 92-343-1-007
. . . . . . . . . . . . . . . . . . . . . 1 92-032-1-002
. . . . . . . . . . . . . . . . . . . . . 1 CH
. . . . . . . . . . . . . . . . . 1 CH
. . . . . . . . . . . . . . . . . . . . . 1 CH
E2
24
E4 E3
40
E1
(ORDERED
26
SEPARATELY)
24
1
33
37
21
32
26
33
27
21
3
36
24
32
24
17
42
18
4
42
26
35
28
14
30
12
42
41
45
13
11
FIGURE 5 (1 OF 3)
NO. DESCRIPTION
19 1/4" Plug . . . . . . . . . . . . . . . . . . . . . . . . . . . .
20 3/4" Plug . . . . . . . . . . . . . . . . . . . . . . . . . . . .
21 1/2" Union . . . . . . . . . . . . . . . . . . . . . . . . . . .
22 3/4" Union . . . . . . . . . . . . . . . . . . . . . . . . . . .
23 1/4" 90° Elbow . . . . . . . . . . . . . . . . . . . . . . .
24 1/2" 90° Elbow . . . . . . . . . . . . . . . . . . . . . . .
25 3/4" 90° Elbow . . . . . . . . . . . . . . . . . . . . . . .
26 1/2" Tee . . . . . . . . . . . . . . . . . . . . . . . . . . . .
27 1/2" x 1/4" x 1/2" Tee . . . . . . . . . . . . . . . . . .
28 3/4" Tee . . . . . . . . . . . . . . . . . . . . . . . . . . . .
29 3/4" x 1/2" x 3/4" Tee . . . . . . . . . . . . . . . . . .
30 3/4" x 3/4" x 1/2" Tee . . . . . . . . . . . . . . . . . .
31 1/4" x Close Nipple . . . . . . . . . . . . . . . . . . . .
32 1/2" x Close Nipple . . . . . . . . . . . . . . . . . . . .
33 1/2" x 1-1/2" Nipple . . . . . . . . . . . . . . . . . . . .
34 1/2" x 2" Nipple . . . . . . . . . . . . . . . . . . . . . . .
35 1/2" x 2-1/2" Nipple . . . . . . . . . . . . . . . . . . . .
36 1/2" x 5" Nipple . . . . . . . . . . . . . . . . . . . . . . .
37 1/2" x 7" Nipple . . . . . . . . . . . . . . . . . . . . . . .
38 Select Nipple per Table . . . . . . . . . . . . . . . .
39 Select Nipple per Table . . . . . . . . . . . . . . . .
40 Select Nipple per Table . . . . . . . . . . . . . . . .
41 3/4" x Close Nipple . . . . . . . . . . . . . . . . . . . .
42 3/4" x 1-1/2" Nipple . . . . . . . . . . . . . . . . . . . .
43 3/4" x 2" Nipple . . . . . . . . . . . . . . . . . . . . . . .
44 3/4" x 4" Nipple . . . . . . . . . . . . . . . . . . . . . . .
45 Select Nipple per Table . . . . . . . . . . . . . . . .
E1 Solenoid Valve Ordered Separately
Per Data Sheet TFP2180 . . . . . . . . . . . . . . .
E2 1/2" Tubing Connector . . . . . . . . . . . . . . . . .
E3 1/2" x 24" Tubing . . . . . . . . . . . . . . . . . . . . .
E4 1/2" x 1-1/2" Nipple . . . . . . . . . . . . . . . . . . . .
COMPONENTS ORDERED SEPARATELY:
A1 Water ow Pressure Alarm Switch,
Model PS10-2 . . . . . . . . . . . . . . . . . . . . . . . .
Select Appropriate Nipple Sizes
Nipple
per DV-5 Deluge Valve Size
Number
1-1/2" (DN40)
38 1/2" x 1-1/2"
39 1/2" x 2"
40 1/2" x 5"
45 3/4" x 1-1/2"
NOTES:
1. Electric Actuation Trim is comprised of
Items 1-45 plus Items E2-E4. Items A1
and E1 ordered separately.
2. All Fittings and Nipples are galvanized
(Standard Order).
3. CH: Common Hardware.
4. See Figure 2 of TFP1305 for Valve Port
identi cation.
5. Route all Tubing to Drip Funnel, Item 14.
6. Horizontal Arrangement uses only 7 out of
8 of Item 24, and 9 out of 10 of Item 33.
Discard unused material.
Step 4. Drain tubing to the Drip Funnel
must be installed with smooth bends
that will not restrict flow.
Step 5. The main drain and Drip Funnel
drain may be interconnected provided
a check valve is located at least 12
inches (300 mm) below the Drip Funnel.
Step 6. Suitable provision must be
made for disposal of drain water. Drain-
age water must be directed such that
it will not cause accidental damage to
property or danger to persons.
Step 7. Connect the Diaphragm Cham-
ber Supply Control Valve to the inlet
side of the system's Main Control Valve
in order to facilitate setting of the DV-5
Valve (Ref. Figure 4).
Step 8. Unused pressure alarm switch
connections must be plugged.
QTY. P/N
1 CH
1 CH
5 CH
2 CH
1 CH
8 CH
1 CH
3 CH
3 CH
2 CH
2 CH
1 CH
2 CH
3 CH
10 CH
1 CH
4 CH
2 CH
1 CH
1 CH
1 CH
1 CH
1 CH
8 CH
1 CH
1 CH
1 CH
Refer to
1 Data Sheet
1 CH
1 CH
1 CH
1 25710
2" (DN50)
1/2" x 2"
1/2" x 1-1/2"
1/2" x 5-1/2"
3/4" x 2-1/2"