Perkins 1206A-E70TTA Operation And Maintenance Manual page 104

104
Index Section
General Coolant Information ....................... 50
Fluid Recommendations (Engine Oil
Specification) ................................................. 54
Engine Oil .................................................... 55
General Lubricant Information..................... 54
Fluid Recommendations (General Fuel
Information) ................................................... 57
Contamination Control Recommendations for
Fuels .......................................................... 64
Diesel Fuel Characteristics.......................... 59
Diesel Fuel Requirements ........................... 57
General Information..................................... 57
Renewable and Alternative Fuels................ 65
Foreword ........................................................... 4
California Proposition 65 Warning ................. 4
Literature Information .................................... 4
Maintenance .................................................. 4
Maintenance Intervals ................................... 5
Operation ....................................................... 4
Overhaul ........................................................ 5
Safety............................................................. 4
Fuel and the Effect from Cold Weather ........... 46
Fuel Conservation Practices ........................... 43
Fuel Related Components in Cold Weather ... 47
Fuel Filters ................................................... 47
Fuel Heaters ................................................ 47
Fuel Tanks ................................................... 47
Fuel System - Prime ........................................ 86
Fuel System Primary Filter (Water
Separator) Element - Replace....................... 87
Install the New Filter Element...................... 90
Off Engine Primary Fuel Filter Remove....... 88
On Engine Primary Fuel Filter Element
Remove...................................................... 89
Fuel System Primary Filter/Water
Separator - Drain ........................................... 90
Off Engine Primary Filter Water Separator
Drain........................................................... 91
On Engine Primary Filter Water Separator
Drain........................................................... 91
Fuel System Secondary Filter - Replace ........ 91
Install the Element ....................................... 92
Remove the Element ................................... 92
Fuel Tank Water and Sediment - Drain ........... 93
Drain the Water and the Sediment .............. 93
Fuel Storage Tanks...................................... 93
Fuel Tank ..................................................... 93
G
Gauges and Indicators .................................... 33
Indicator Lamps ........................................... 34
General Hazard Information.............................. 9
Containing Fluid Spillage..............................11
Dispose of Waste Properly .......................... 12
Fluid Penetration ..........................................11
Inhalation ..................................................... 12
Pressurized Air and Water............................11
Static Electricity Hazard when Fueling with
Ultra-low Sulfur Diesel Fuel ........................11
General Information ........................................ 22
H
High Pressure Fuel Lines ................................ 16
Hoses and Clamps - Inspect/Replace............. 93
Replace the Hoses and the Clamps ............ 94
I
Important Safety Information............................. 2
L
Lifting and Storage .......................................... 30
M
Maintenance Interval Schedule....................... 69
Daily ............................................................. 69
Every 1000 Service Hours........................... 69
Every 12 000 Service Hours or 6 Years....... 69
Every 2000 Service Hours........................... 69
Every 3000 Service Hours........................... 69
Every 3000 Service Hours or 2 Years ......... 69
Every 4000 Service Hours........................... 69
Every 4500 Service Hours........................... 69
Every 50 Service Hours or Weekly.............. 69
Every 500 Service Hours ............................. 69
Every 500 Service Hours or 1 Year ............. 69
Every 6000 Service Hours or 3 Years ......... 69
Every Week ................................................. 69
When Required............................................ 69
Maintenance Log........................................... 101
Maintenance Recommendations .................... 66
Maintenance Records ................................... 100
Maintenance Section....................................... 50
Model View Illustrations .................................. 22
Engine Only ................................................. 23
Full Engine Views ........................................ 22
Monitoring System (Engine Indicators) ........... 34
Engine Indicator Lamps............................... 34
Mounting and Dismounting ............................. 16
M0090743