Parts Bag & Controls; Instruction Labels; Engine Labels - Billy Goat HTR1602V Operator Owner's Manual

PARTS BAG & LITERATURE ASSY P/N 811201
12
Washer 5/16
79
Fender
8172020 Qty. 4
Washer 5/16 SAE
4
8172008 Qty. 4
Nut Lock 1/4-20
52
8160001 Qty. 4
Nut Lock 5/16-18
5
8160002 Qty. 3
Washer 5/16
FLAT CUT
6
8171003 Qty. 1
Screw Cap 5/16-18 x 1 1/2
80
8041030 Qty. 3
Screw Cap 1/4-20 x 1 3/
55
4 8041009 Qty. 2

INSTRUCTION LABELS

14
These labels should be included on your Vacuum. If any of these
labels are damaged, replace them before putting this equipment into
operation. Item and part numbers are given to help in ordering
replacement labels..
Label Danger Keep Hands
Label Danger Flying Material
and Feet Away
Item No. 19 Part No. 810736
Item 3 Part No.400424
Label Ear Eye Breathing
Item No. 48 Part No. 890254
WARNING
EXPLOSIVE FUEL
STOP ENGINE AND ALLOW T O
COOL BEFORE REFUELING.
Label Do Not Fill While Engine Is Hot
Item 81 Part No.400268
Clean debris from all engine surfaces
regularly to prevent engine overheating,
premature failure, or fire.
Part No. 811202
Chain Loop Assy
54
810878 Qty. 2
DANGER
Label Read Owner's Manual
Item 15 Part No.830301
READ OWNER'S MANUAL
USE PROTECTION
BEFORE OPERATING, MAKE SURE:
EXHAUST ELBOW IS ATTACHED.
EXHAUST IS DISCHARGING INTO
ENCLOSED CONTAINER.
HOSE IS ATTACHED.
ALL GUARDS ARE ATTACHED.
OPERATING INSTRUCTION IS OBTAINED.
STOP ENGINE AND ALLOW T O
COOL BEFORE REFUELING.
KEEP ENGINE CLEAN OF DEBRIS.
INSPECT MACHINE BEFORE EACH USE AND REPLACE ANY
WORN AND DAMAGED PARTS.
PROPERLY SECURE EQUIPMENT BEFORE TRANSPORTING.
NEVER SERVICE UNIT WITHOUT DISCONNECTING SPARK PLUG WIRE.
USE ONLY A QUALIFIED MECHANIC TO SER VICE THIS MACHINE.
ABRASIVE DEBRIS WILL SHORTEN UNIT LIFE.
Label Caution
Item 47 Part No.830138
Label Warning Engine Overheat
Item 49 Part No.811215
Literature Checklist
Check
Owner's
Manual
Check
Literature
Parts Bag
Check
Literature
HTR / TR
Accessories
Check
Warranty
Card
Check
EU Declaration
of Conformity
& EU
Distributor List

ENGINE LABELS

15
Briggs & Stratton Vanguard
STOP
RUN
Honda
OIL ALERT
WHEN OIL LEVEL LOW,
ENGINE STOPS IMMEDIATELY.
H O N D A M O T O R C O ., L T D . M
Briggs & Stratton
ON
OFF
RUN CHOKE
THIS ENGINE EQUIPPED WITH
LOW OIL SENSOR, IF ENGINE WILL
NOT START, CHECK OIL LEVEL
Page 4 of 12
13 CONTROLS
Throttle Controls
Honda
Units have
Owner's
frame
Manual mounted
throttle
811202
controls as
shown
Literature here.
Parts Bag
811203
Literature
HTR / TR
Briggs Vanguard Units
Accessories
have an engine mounted
811208
throttle control.
Engine
Stop
Warranty
Switch
Card
400972
Start
position
EU Declaration
of Conformity &
EU Distributor
List 811204
Stop
position
FUEL SHUTOFF FUEL SHUTOFF
ON
RUN
CHOKE
OFF
ENGINE MAINTENANCE
1. CHECK OIL LEVEL 8 HOURS
2. CHECK & CLEAN AIR CLEANER 25 HOURS
3. CHANGE OIL 50 HOURS
4. REPLACE OIL FILTER 100 HOURS
5. CLEAN COOLING FINS 100 HOURS
See Operating and Maintenance Instructions
A D E I N J A PA N
Read and follow Operating
Instructions before running engine.
Gasoline is flammable. Allow engine
to cool at least 2 minutes before fueling.
Engines emit carbon monoxide,
DO NOT run in enclosed area.
Form No. F072402A
Start
position
START
STOP
Stop
position