Fuel Types; Diesel Exhaust Fluid (Def); Pintle Hook; Attachments - Xtreme xr1255 Operation And Safety Manual

Operation

Fuel Types

Use of improper grade of fuel may result in damage to en-
gine or exhaust aftertreatment system.
Use ASTM #2 diesel fuel with a minimum Cetane rating of
40 for better fuel economy and performance under most
operating conditions.
• Use standard #2 diesel fuel for operating at temperatures
above 32°F (0°C).
• Use a blend of #1 and #2 diesel fuel ("winterized" #2 diesel)
for operating at temperatures below 32°F (0°C).
• Fuels with Cetane ratings higher than 40 may be needed
in higher altitude or in an extremely low temperature
climate to prevent hard starts and excessive smoke.
Use only Ultra Low Sulfur fuel. Maximum sulfur content: 15
ppm.

Diesel Exhaust Fluid (DEF)

The DEF tank should be filled after every fuel refill. DEF should
be added when the Low DEF Level indicator is displayed.
Refer to the Operation section on Warning Indicators and
Fault Codes and the Engine Indicator Chart (Fig. 65). The total
capacity of the DEF tank is 5 gallons.
If no DEF reagent is available in the DEF tank, the emission
requirements cannot be fulfilled and the machine derates
eventually to idle only, following a predetermined schedule.
Use DEF meeting ISO 22241-1. There is NO acceptable
substitute. Using anything other than DEF fluid may result
in permanent aftertreatment damage.
Caution
Caution
Warning
Warning

Pintle Hook

Death or serious injury could result from im-
proper operation when using tow connection.
Do not elevate boom above 30 degrees when
towing. Do not exceed rated tow capacity
(500 lbs vertical load, 5,000 lbs tow capacity.
The Pintle Hook is used for towing trailers and equipment, rat-
ed at or below 5,000 lbs maximum capacity. Failure to comply
with this capacity limitation, or elevating the boom above 30
degrees when towing could result in death or serious injury.
Figure 65. Pintle Hook

Attachments

Attachment Disclaimer

DO NOT exceed the manufacturer's rated
load for any auxiliary attachment.
attempt to lift or carry loads in excess of the
manufacturer's rated load may cause forklift
tip over, loss of load, or structural damage
which could result in death, serious injury, or property
damage.
Xtreme Manufacturing makes no representations or warranties,
expressed or implied, as to the design, manufacture, or fitness
for use with this forklift of any third party attachment. This
forklift is not intended to be used and should not be used with an
attachment that would alter the center of gravity or stability of
this forklift. Xtreme Manufacturing assumes no liability for any
third party attachment that would alter the center of gravity or
stability.
59
Warning
Operation Manual
Any