Vent Lines; Fuel System; Fuel Filter - Polaris RZR 170 2009 Service Manual

Vent Lines

1. Check fuel tank, crankcase, carburetor and transmission
vent lines for signs of wear, deterioration, damage or
leakage. Replace every two years.
2. Verify vent lines are routed properly and secured with
cable ties.

Fuel System

WARNING
Gasoline is extremely flammable and explosive
under certain conditions.
Always stop the engine and refuel outdoors or in
a well ventilated area.
Do not smoke or allow open flames or sparks in
or near the area where refueling is performed or
where gasoline is stored.
Do not overfill the tank. Do not fill the tank neck.
If you get gasoline in your eyes or if you swallow
gasoline, seek medical attention immediately.
If you spill gasoline on your skin or clothing,
immediately wash it off with soap and water
and change clothing.
Never start the engine or let it run in an enclosed
area. Engine exhaust fumes are poisonous and
can result loss of consciousness or death
in a short time.
Never drain the fuel when the engine is hot.
Severe burns may result.

Fuel Filter

The fuel filter should be replaced in accordance with the
"Periodic Maintenance Chart" or whenever sediment is visible
in the filter.
Fuel Filter Location - Located in-line between fuel pump
and carburetor inlet.
To service the fuel filter:
1. Shut off fuel supply at fuel valve.
2. Remove line clamps at both ends of the filter.
3. Remove fuel lines from filter.
4. Install new filter and clamps onto fuel lines.
5. Turn fuel valve to 'ON'.
6. Start engine and inspect for leaks.
MAINTENANCE
2.15
2