Bay Tek Games Big Bass Wheel Service Manual page 53

PROBLEM
SOLENOID ALWAYS
STAYS ON.
PLAYERS CAN SPIN THE
WHEEL WITHOUT
COINING UP.
DURING ATTRACT MODE
THE GAME MAKES A
LOUD CLICKING SOUNDS
AS THE WHEEL SPINS.
PHYSICAL METERS DO
NOT WORK.
MONITOR SHOWS
"OUT OF ORDER-DOOR
OPEN".
MOTOR WATCHDOG
ERROR.
BAY TEK GAMES, INC.
TROUBLESHOOTING GUIDE
TROUBLESHOOTING GUIDE
TROUBLESHOOTING GUIDE-SCORING ISSUES
PROBABLE CAUSE
A. JAMMED SOLENOID.
B. MISSING OR BROKEN SPRINGS.
C. PINCHED CABLE.
D. FAULTY I/O BOARD.
A. TICKET METER SHOULD "CLICK" AS
TICKETS ARE BEING DISPENSED.
B. GAMES METER SHOULD "CLICK" AS
GAMES ARE STARTED.
C. FAULTY I/O BOARD.
A. ONE OR MORE OF THE DOORS ARE
OPEN.
B. FAULTY DOOR LIMIT SWITCH.
C. I/O SERIAL CABLE UNPLUGGED.
D. FAULTY I/O BOARD.
A. ENCODER SENSOR FAULTY.
B. FAULTY MOTOR.
AFTER THE PROBLEM IS FOUND AND FIXED:
1. ENTER THE OPERATOR MENU AND
ENSURE THE PLAYER TIME OUT IS SET TO
"MOTOR ASSIST".
2. TURN GAME OFF, THEN BACK ON, COIN UP
BUT DO NOT SPIN THE WHEEL.
LET THE GAME SPIN WHEEL.
3. ENTER THE MENU AND VERIFY THE
"MOTOR WATCHDOG" ERROR IS NOT
PRESENT.
BIG BASS WHEEL SERVICE MANUAL
REMEDY
A. INSPECT SOLENOID, ENSURE IT WORKS
PROPERLY.
B. LOOK FOR MISSING SPRINGS. REPLACE
ASSEMBLY IF NEEDED (AASO1450).
C. INSPECT PHONE CABLES.
D. REPLACE I/O BOARD (AACB1900).
A. WATCH AS THE TICKETS DISPENSE,
REPLACE COUNTERS IF NEEDED (AACO1000).
B. WATCH AS THE NEXT GAME STARTS,
REPLACE COUNTERS IF NEEDED (AACO1000).
C. REPLACE I/O BOARD (AACB1900).
A. REFER TO THE "DOOR OPEN" SECTION.
B. REPLACE THE LIMIT SWITCH (A5SW7000).
C. INSPECT AND RE-SEAT SERIAL CABLE
FROM THE MOTHERBOARD TO THE I/O BOARD.
D. REPLACE I/O BOARD (AACB1900).
A. CLEAN ENCODER SENSOR ON THE LEFT
SIDE OF THE WHEEL.
B. REFER TO THE "MOTOR WILL NOT ASSIST"
SECTION ON PAGE 50.
Page 53