Tracker System Wiring - EMS Sky Connect Series Installation Manual

TRANSCEIVER
JP1
12
01 02 4 +28V DC 21
22
+28V DC 42 22 SKY1A18S W
+28V DC 62 22 SKY1A18S B
1
GND 1
22
GND 22 22
GND 43
22
#1 RS232 DATA IN 52 SKY30A22S W
GPS DATA FROM GPS, AVIATION OR NMEA-0183 MARINE
#1 RS232 DATA OUT 31 SKY30A22S B
#2 RS232 DATA IN HI 50 SKY31A22S W
#2 RS232 DATA OUT HI 48 SKY31A22S B MESSENGER DATA TO/FROM RS232 DEVICE
#2 RS232 LO 32 SKY31A22S O
RS232 GND 10
EVENT SWITCH 1 20 SKY40A22
EVENT SWITCH 2 61 SKY41A22
EVENT SWITCH 3 60 SKY42A22
EVENT SWITCH 4 59 SKY43A22
EVENT SWITCH 5 58 SKY44A22
EVENT SWITCH 6 57 SKY45A22
EVENT SWITCH 7 56 SKY46A22
EVENT SWITCH 8 55 SKY47A22
31
ANNUNCIATOR #1 15 SKY50A22S G
ANNUNCIATOR #2 16
ANNUNCIATOR #3 17
ANNUNCIATOR #4 18
15 20 21 23 P10
CONFIG DATA OUT 47 SKY64B22S W 2
CONFIG DATA IN 49 SKY64B22S B 3
CONFIG GND 30 SKY64B22S O 5
SHIELD 13 Diagnostic
21
Connector
OR
13 18 22 23 PJ20
CONFIG DATA OUT 47 SKY60A22S W 2
CONFIG DATA IN 49 SKY60A22S B 3
CONFIG GND 30 SKY60A22S O 5
CONFIG PWR 12 SKY62A22S W 6
CONFIG SCL 28 SKY62A22S B 8
CONFIG SDA 19 SKY62A22S O 9
DPL ENABLE 26 SKY61A22S W 13
DPL GND 9 SKY61A22S B 17
15
DPL Tx 4 SKY65A22S W
DPL Rx 25 SKY65A22S B 14
SHIELD 11
19
09
7 11
IRIDIUM ANTENNA TNC SKY102A
10
7 8 11
GPS ANTENNA BNC SKY109A
OR
09
7 11
IRIDIUM ANTENNA TNC SKY102A
GPS ANTENNA BNC SKY109A
11
10 7 8
6
2
SKY50B22S TO DIMMER BUSS
12
CONFIGURATION MODULE
14 20 22 24 15 20 21 23
JP9 P10
05
9
CONFIG DATA IN DATA OUT 2 SKY64B22S W 2
CONFIG DATA OUT DATA IN 3 SKY64B22S B 3
CONFIG GND DATA LO 5 SKY64B22S O 5
CONFIG PWR Diagnostic
21
CONFIG SCL
Connector
CONFIG SDA
DPL POWER
DPL GND
DPL Rx
DPL Tx
07
09
TNC
08
09
TNC
09
06
TNC
TNC
09
NON ESS
BUSS
29
3
Revision History
Rev Date
1.0 11/7/06 Recreated drawing.

TRACKER SYSTEM WIRING

(1616-910-02)
Tracker Dash Numbers
Description
#
-01A Tracker with GPS
-02A Tracker no GPS
-03A Tracker with Phone and GPS
-04A Tracker with Phone and no GPS
-05A Tracker AFF with GPS
This data is provided as a CONFIDENTIAL and PRIVILEGED DOCUMENT by EMS Aviation.
reproduction without the expressed written consent of EMS Aviation is expressly forbidden.
document including (but not limited to) quotation in part without written consent of EMS Aviation is expressly forbidden.
Drawn
All dimensions are in inches unless
Michael Freyder 01/31/2005
otherwise specified.
Dimensions marked:
Revised
[X.XX] REF are existing geometry,
Christopher Malpass 08/16/2011
and are supplied as reference only.
[X.XX] TYP are typical dimensions
Checked / Approved
are are supplied as reference only
Michael Freyder 08/16/2011
Tolerances, unless otherwise
DER Review
specified:
x.x ± .05"
x.xx ± .01"
Filename
x.xxx ± .005"
1616-910.dwg
x° ± 2°
Description
Any other use or
Any misuse of this
Sky Connect Tracker Installation
Drawing Number
1616-910
Size Sheet Scale Rev
B 2 of 4 N/A 1.0