Electrical Schematic Parts List Models 3220, 4620, 4626, 4830 & 4832 With All Options (Ce) - Skyjack SJIII 3220 Operating & Maintenance Manual

Models 3220, 4620, 4626, 4830 & 4832 With All Options (CE)
Skyjack
Ref.
Part No.
No.
B1-B4 $ BATTERY, 6 Volt (Trojan #T2200) (Models 3220, 4620 & 4626)
$ BATTERY, 6 Volt (Trojan #J250) (Model 4830 & 4832)
BC 112255 BATTERY CHARGER ASSEMBLY (Bycan #2440A)
113415 BATTERY CHARGER ASSEMBLY (Bycan #2440E)
BCI 103240 BATTERY CHARGE INDICATOR
BP-29 103057 BEEPER, 24 Volt
BP-29A 117967 BEEPER, LWS 9-28 Volt DC
C1 103101 CONTACTOR, 24 Volt motor
CAP1 110699 CAPACITOR .47UF 50 Volts
CAP2 $ CAPACITOR, LWS (Not a servicable part)
CB1-CB2 117325 CIRCUIT BREAKER, 15 Amp
13BCR 108589 RELAY, 24 Volt (LWS time delay cutout)
17CR 108589 RELAY, 24 Volt (transfer)
21ACR 108589 RELAY, 24 Volt (proportional)
28CR 108589 RELAY, 24 Volt (tilt switch)
39CR 108589 RELAY, 24 Volt (LWS limit switch)
41CR 117625 RELAY, 24 Volt (LWS time delay)
42CR 108589 RELAY, 24 Volt (LWS latching)
DCM1 106576 MOTOR, 24 Volt
D02-X 700166 DIODE, Flyback 1 Amp 400PIV
DXX 102921 DIODE, 6 Amp 1000PIV
DA1 119758 DIODE PACK
DA2 119520 DIODE ASSEMBLY
DA3 119624 DIODE ASSEMBLY
F1 117619 FUSE, 300 Amp
F2 114866 FUSE, 1 Amp (tilt switch)
FL-XX 103267 FLASHER, 24 Volt
FL-XX 121838 FLASHING LIGHT (option)
H1 102860 HORN, Operator
2H-13A 103605 COIL, 24 Volt (down valve)
2H-13A-X 104493 COIL, 24 Volt (holding valve)
2H-18A 103605 COIL, 24 Volt (differential valve) (Models 3220, 4620, 4626, 4830 & 4832)
2H-59B 115370 COIL, 24 Volt (proportional valve)
3H-14A 105610 COIL, 24 Volt (lift valve)
3H-17A 103605 COIL, 24 Volt (brake valve)
3H-18A1 103605 COIL, 24 Volt (speed A) (Models 3220, 4620, 4626, 4830 & 4832)
3H-18A2 103605 COIL, 24 Volt (speed B) (Models 3220, 4620, 4626, 4830 & 4832)
4H-15 107439 COIL, 24 Volt (reverse drive spool valve)
4H-16 107439 COIL, 24 Volt (forward drive spool valve)
4H-23 107439 COIL, 24 Volt (right steer spool valve)
4H-24 107439 COIL, 24 Volt (left steer spool valve)
4H-26 107439 COIL, 24 Volt (powered platform extend spool valve) (option)
4H-27 107439 COIL, 24 Volt (powered platform retract spool valve) (option)
L1CR 115315 RELAY, Battery charger
LB1 102671 LIGHT, Overload (option)
LS1 119957 LIMIT SWITCH, High speed
LS2 115658 LIMIT SWITCH, Powered extension platform 3 ft. (option)
LS3 102688 LIMIT SWITCH, End of stroke (option)
LS4 119348 LIMIT SWITCH, Pothole protection (battery tray)
LS5 119348 LIMIT SWITCH, Pothole protection (hydraulic tray)
LS6 102668 LIMIT SWITCH, Drive override
LS7 102847 LIMIT SWITCH, 26' Drive cutout(4830 & 4832)
LWS 118717 LWS MODULE
PS1 102863 PRESSURE SWITCH
RST1 119629 RESISTOR, 2.7K
RST2 115313 RESISTOR, 25W-30 Ohm (Models 3220, 4620, 4626, 4830 & 4832)
RST3 116505 RESISTOR, Low voltage protection (option)
S1 102600 SWITCH, Main power disconnect
S2 102853 SWITCH, Up/down toggle
S3 103141 N.O. CONTACT, Base/off/platform key switch
S4 103225 N.C. CONTACT, Emergency stop switch (control box)
S5 116382 SWITCH, Lift/off/drive toggle
S7 115311 CONTROLLER ASSEMBLY, Proportional
S7-1 117150 • CIRCUIT BOARD ASSEMBLY
S8 103141 N.O. Contact, Operator horn
S11 102853 SWITCH, Powered ext. platform extend/retract toggle (option)
S12 102853 SWITCH, Powered extension platform enable toggle (option)
S27 115574 SWITCH, Torque toggle
S28 103225 N.C. CONTACT, Emergency stop switch (base)
TS1 117880 TILT SWITCH ASSEMBLY
T T 103336 HOURMETER
$
SECTION 3, Page 16
FIGURE 3-10. ELECTRICAL SCHEMATIC PARTS LIST
- Purchase locally.
Complete Revision 99-05-01
Description
SJIII Series - The CONVENTIONALS
Units
per
Assy
4
4
1
1
1
1
1
1
1
1
2
1
1
1
1
1
1
1
1
AR
AR
1
1
1
1
1
1
1
1
1
AR
1
1
1
1
1
1
1
1
1
1
1
1
1
1
1
1
1
1
1
1
1
1
1
1
1
1
1
1
2
1
1
1
1
1
1
1
1
1
1
1
117128