Torque Conversions (Ft-Lb/N-M); Gasoline - Oil - Lubricant - Arctic Cat HDX CREW 2017 Service Manual

ENGINE/TRANSMISSION
Part
Engine Cradle/Rubber Mount Rubber Mount/Frame
Engine Cradle Engine
Cam Sprocket** Camshaft
Cylinder (6 mm) Crankcase
Valve Cover Cylinder Head
Tappet Cover Valve Cover
Cylinder Head (Cap Screw) Crankcase
Cylinder Head Nut (6 mm) Cylinder
Cylinder Head Nut (8 mm) Cylinder
Clutch Shoe** Crankshaft
Driven Pulley** Driveshaft
Ground Wire Engine
Magneto Cover Crankcase
Speed Sensor Crankcase
Oil Drain Plug Engine
CVT Cover Clutch Cover/Housing
Movable Drive Face** Centrifugal Clutch Housing
Starter Clutch** Flywheel
Secondary Drive Gear Nut Secondary Drive Gear
Output Drive Flange Nut** Output Shaft
Stator Coil** Magneto Cover (New)
Stator Coil Magneto Cover (Existing)
Oil Strainer Crankcase
Starter Motor Crankcase
Oil Pump** Crankcase
Water Pump/Housing Magneto Cover
Crankcase Half (6 mm) Crankcase Half
Crankcase Half (8 mm) Crankcase Half
Shift Cam Stopper Crankcase
Shift Cam Plate Shift Cam Shaft
Crankshaft Bushing Crankshaft
Oil Pump Drive Gear** Crank Balancer Shaft
Outer Magneto Cover Left-Side Cover
Secondary Shaft Bearing Crankcase Half
Housing**
* w/Blue Loctite #243 ** w/Red Loctite #271
*** w/Green Loctite #270 **** w/"Patch-Lock"
4
Torque
Part Bolted To
ft-lb
25
43
10
10
8.5
8.5
(step 1) 20
(step 2) 30
(final) 37
10
18
221
162
8
10
8
16
44 in.-lb
162
26
200
200
13
11.5
54 in.-lb
10
8.5
8
10
21
8
8
28
63
8.5
25
Torque Conversions (ft-lb/
N-m
34
58
13.5
ft-lb N-m ft-lb
13.5
1 1.4 26
11.5
2 2.7 27
11.5
3 4.1 28
27
41
4 5.4 29
50
5 6.8 30
13.5
6 8.2 31
24.5
7 9.5 32
300
8 10.9 33
220
9 12.2 34
11
10 13.6 35
13.5
11 15 36
11
12 16.3 37
22
13 17.7 38
5
14 19 39
220
15 20.4 40
35
16 21.8 41
271
17 23.1 42
271
18 24.5 43
18
19 25.8 44
15
20 27.2 45
6
21 28.6 46
13.5
22 29.9 47
11.5
23 31.3 48
11
24 32.6 49
13.5
25 34 50
28
11

Gasoline - Oil - Lubricant

11
38
85
FILLING GAS TANK
11.5
34
! WARNING
Always fill the gas tank in a well-ventilated area. Never add
fuel to the gas tank near any open flames or with the engine
running. DO NOT SMOKE while filling the gas tank.
Since gasoline expands as its temperature rises, the gas tank
must be filled to its specified capacity only. Expansion room
must be maintained in the tank particularly if the tank is filled
with cold gasoline and then moved to a warm area.
! WARNING
Do not overflow gasoline when filling the gas tank. A
fire hazard could materialize. Always allow the engine to
cool before filling the gas tank.
Tighten the gas tank cap securely after filling the tank.
! WARNING
Do not over-fill the gas tank.
RECOMMENDED GASOLINE
The recommended gasoline to use is 87 minimum octane
regular unleaded. In many areas, oxygenates are added to
the gasoline. Oxygenated gasolines containing up to 10%
ethanol or 5% methane are acceptable gasolines.
N-m)
N-m ft-lb N-m ft-lb
35.4 51 69.4 76
36.7 52 70.7 77
38.1 53 72.1 78
39.4 54 73.4 79
40.8 55 74.8 80
42.2 56 76.2 81
43.5 57 77.5 82
44.9 58 78.9 83
46.2 59 80.2 84
47.6 60 81.6 85
49 61 83 86
50.3 62 84.3 87
51.7 63 85.7 88
53 64 87 89
54.4 65 88.4 90
55.8 66 89.8 91
57.1 67 91.1 92
58.5 68 92.5 93
59.8 69 93.8 94
61.2 70 95.2 95
62.6 71 96.6 96
63.9 72 97.9 97
65.3 73 99.3 98
66.6 74 100.6 99
68 75 102 100
N-m
103.4
104.7
106.1
107.4
108.8
110.2
111.5
112.9
114.2
115.6
117
118.3
119.7
121
122.4
123.8
125.1
126.5
127.8
129.2
130.6
131.9
133.3
134.6
136