While Operating - Toro 41199 Operator's Manual

•
Never allow children to operate the sprayer.
•
Never allow other adults to operate the sprayer without
first reading and understanding the Operator's Manual.
Only trained and authorized persons should operate this
sprayer. Make sure that all operators are physically and
mentally capable of operating the sprayer.
•
This sprayer is designed to carry only you, the operator.
Never carry any passengers on the sprayer.
•
Never operate the sprayer when under the influence
of drugs or alcohol. Even prescription drugs and cold
medicines can cause drowsiness.
•
Do not drive the sprayer when you are tired. Be sure to
take occasional breaks. It is very important that you stay
alert at all times.
•
Become familiar with the controls and know how to stop
the engine quickly.
•
Keep all shields, safety devices, and decals in place. If a
shield, safety device, or decal is malfunctioning, illegible,
or damaged, repair or replace it before operating the
machine.
•
Always wear substantial shoes. Do not operate the
machine while wearing sandals, tennis shoes, or sneakers.
Do not wear loose fitting clothing or jewelry which could
get caught in moving parts and cause personal injury.
•
Wearing safety glasses, safety shoes, long pants, and a
helmet is advisable and required by some local safety and
insurance regulations.
•
Avoid driving when it is dark, especially in unfamiliar
areas. If you must drive when it is dark, be sure to drive
cautiously, use the headlights, and even consider adding
additional lights.
•
Be extremely careful when operating around people.
Always be aware of where bystanders might be and keep
them away from the work area.
•
Before operating the sprayer, always check the designated
areas of the sprayer that are stated in the Pre-Starting
Checks in the Operation section. If the machine does
not function correctly or is damaged in any way, do not
use the sprayer. Make sure that the problem is corrected
before the sprayer or attachment is operated.
•
Ensure that all fluid line connectors are tight and all hoses
are in good condition before applying pressure to the
system.
•
Since gasoline is highly flammable, handle it carefully.
– Use an approved gasoline container.
– Do not remove the cap from the fuel tank when the
engine is hot or running.
– Do not smoke while handling gasoline.
– Fill the fuel tank outdoors, and fill it to about 1 inch
(25 mm) below the top of the tank (the bottom of the
filler neck). Do not overfill it.
– Wipe up any spilled gasoline.

While Operating

WARNING
Engine exhaust contains carbon monoxide, which
is an odorless, deadly poison that can kill you.
Do not run engine indoors or in an enclosed area.
•
The operator should remain seated whenever the sprayer
is in motion. The operator should keep both hands on
the steering wheel whenever possible. Keep your arms
and legs within the sprayer body at all times.
•
Always watch out for and avoid low overhangs such as
tree limbs, door jambs, and overhead walkways. Make
sure there is enough room over head to easily clear the
sprayer and your head.
•
Failure to operate the sprayer safely may result in an
accident, tip over of the sprayer, and serious injury or
death. Drive carefully. To prevent tipping or loss of
control:
– Use extreme caution, reduce speed, and maintain
a safe distance around sand traps, ditches, creeks,
ramps, unfamiliar areas, or any areas that have abrupt
changes in ground conditions or elevation.
– Watch for holes or other hidden hazards.
– Use extra caution when operating the sprayer on wet
surfaces, in adverse weather conditions, at higher
speeds, or with a full load. Stopping time and distance
will increase with a full load.
– Avoid sudden stops and starts. Do not go from
reverse to forward or forward to reverse without first
coming to a complete stop.
– Slow down before turning. Do not attempt sharp
turns or abrupt maneuvers or other unsafe driving
actions that may cause a loss of sprayer control.
– Before backing up, look to the rear and ensure that
no one is behind you. Back up slowly.
– Watch out for traffic when you are near or crossing
roads. Always yield the right of way to pedestrians
and other vehicles. This sprayer is not designed for
use on streets or highways. Always signal your turns
or stop early enough so that other people know what
you plan to do. Obey all traffic rules and regulations.
– The electrical and exhaust systems of the sprayer can
produce sparks capable of igniting explosive materials.
Never operate the sprayer in or near an area where
there is dust or fumes in the air which are explosive.
– If you are ever unsure about safe operation, stop
work and ask your supervisor.
•
Do not touch the engine or muffler while the engine is
running or soon after it has stopped. These areas may be
hot enough to cause burns.
5