Safety; Safe Operating Practices; Supervisor's Responsibilities; Before Operating - Toro 07379 Operator's Manual

Safety

Safe Operating Practices

WARNING
The Workman is an off–highway vehicle only, and
is not designed, equipped, or manufactured for use
on public streets, roads, or highways.
This machine was designed and tested to offer safe service
when operated and maintained properly. Although hazard
control and accident prevention partially depend upon the
design and configuration of the machine, these factors also
depend upon the awareness, concern, and proper training of
the personnel involved in the operation, maintenance and
storage of the machine. Improper use or maintenance of the
machine can result in injury or death.
This is a specialized utility vehicle designed for off–road use
only. Its ride and handling will have a different feel than what
drivers experience with passenger cars or trucks. So take time
to become familiar with this vehicle.
Not all the attachments that adapt to the Workman are
covered in this manual. See the specific Operator's Manual
provided with each attachment for additional safety
instructions. Read these manuals.
To reduce the potential for injury or death, comply with
the following safety instructions.

Supervisor's Responsibilities

•
Make sure that all operators are thoroughly trained and
familiar with the Operator's Manual and all labels on the
vehicle.
•
Be sure to establish your own special procedures and
work rules for unusual operating conditions (e.g., slopes
too steep for vehicle operation). Use the 3rd high lockout
switch if driving at high speed could endanger you and
others or damage the vehicle.

Before Operating

•
Operate the machine only after reading and understanding
the contents of this manual. A replacement manual is
available by sending complete model and serial number
to: The Toro Company, 8111 Lyndale Avenue South,
Minneapolis, Minnesota 55420.
•
Never allow children to operate the machine. Never
allow adults to operate it without proper instructions.
Only trained and authorized persons should operate this
machine. Make sure that all operators are physically and
mentally capable of operating the machine.
•
This machine is designed to carry only you, the operator,
and 1 passenger in the seat provided by the manufacturer.
Never carry any other passengers on the vehicle.
•
Never operate the machine when under the influence
of drugs or alcohol.
•
Become familiar with the controls and know how to stop
the engine quickly.
•
Keep all shields, safety devices, and decals in place. If
a shield, a safety device, or a decal is malfunctioning,
illegible, or damaged, repair or replace it before operating
the machine.
•
Always wear substantial shoes. Do not operate the
machine while wearing sandals, tennis shoes, or sneakers.
Do not wear loose fitting clothing or jewelry which could
get caught in moving parts and cause personal injury.
•
Wearing safety glasses, safety shoes, long pants, and a
helmet is advisable and required by some local safety and
insurance regulations.
•
Keep everyone, especially children and pets, away from
the areas of operation.
•
Before operating the machine, always check all parts of
the vehicle and any attachments. If something is wrong,
stop using the machine. Make sure that the problem is
corrected before operating the machine or the attachment.
•
Since diesel fuel is highly flammable, handle it carefully.
– Use an approved fuel container.
– Do not remove the cap from the fuel tank when the
engine is hot or running.
– Do not smoke while handling fuel.
– Fill the fuel tank outdoors and to about 1 inch below
the top of tank (bottom of filler neck). Do not
overfill the tank.
– Wipe up any spilled fuel.
•
Operate the machine only outdoors or in a well-ventilated
area.
•
Use only an approved nonmetal, portable fuel container.
Static electric discharge can ignite fuel vapors in a
ungrounded fuel container. Remove the fuel container
from the bed of the vehiclee and place it on the ground
away from the vehicle before filling. Keep the nozzle
in contact with the container while filling. Remove the
equipment from vehicle bed before filling the tank.
•
Check the safety interlock system daily for proper
operation. If a switch malfunctions, replace the switch
before operating the machine.

Operation

•
The operator and passenger should use seat belts and
remain seated whenever the machine is in motion. The
operator should keep both hands on the steering wheel
whenever possible, and the passenger should use the
hand holds provided. Keep you arms and legs within the
vehicle body at all times. Never carry passengers in the
bed or on attachments. Remember that your passenger
4