Track - BOMBARDIER Skandic 377 IR Shop Manual

TRACK TYPE APPLICATION
Refer to the" Technical Data" section 09.
INSPECTION
Visually inspect track for cuts and abnormal wear. Inspect
track for broken rods. If excessive damage is evident and
rods are broken, replace track. Inspect track for damaged
or missing inserts. Replace damaged insert(s).
•
WARNING: Do not operate a snowmobile with
a cut, torn or damaged track.
REMOVAL
Elan
Remove the following items:
- Tool box
- Chaincase access plug
- Drive axle cotter pin and washer
- Suspension
- Rear axle
- The two drive axle seals
- End bearing housing
- Drive axle
- Track
Citation, Skandic, Skandic "R"
Remove the following items:
- Pulley guard and drive belt
- Air silencer
- Injection oil reservoir (if so equipped)
- Speedometer, angle drive (if so equipped)
- Chaincase cover, sprockets and chain
- Suspension
- Countershaft bearing housing (clamp)
- Brake caliper (Skandic "R")
- Circlip (Skandic "R")
- Brake disc (Skandic "R")
- Key (Skandic "R")
- Drive axle shaft bearing housing (left side)
SECTION 05 SUSPENSION
SUB-SECTION 05 (TRACK)
TRACK
- Drive axle (outwards from left side)
- Upper center idler(s) assembly
- Track
Blizzard, Blizzard MX
Remove the following items:
- Speedometer cable and protector (if so equipped)
- Chaincase cover, sprockets and chain
- Suspension
- Two drive axle seals
- Chaincase
- Drive axle (outwards from chaincase side)
- Upper center idler wheel (if applicable)
- Track
Alpine
Remove the following items:
- Release the chain tensioner of the transmission chain
- Bogie wheels
- Rear axle(s) assembly(ies)
- Drain the transmission oil
- Drive axle seal(s)
- End bearing(s) housing
- Drive axle(s) (outwards from end bearing(s) housing)
- Track(s)
SS-25, Sonic LlC, Safari 377, 377E, 447,
Grand Luxe
Remove the following items:
- Speedometer cable
- Battery and battery support (if so equipped)
- Chaincase cover, sprockets and chain
- Suspension
- Two drive axle seals
- Drive axle (outwards from end bearing housing)
- Track
PAGE 367