Linhai LANDBOSS LH800U-2D Service Manual page 14

CHAPTER 2 MAINTENANCE
MANUA2014.0
Item
l
Air Filter-Main Element
Brake Pad Wear / Parking
D
Brake Pads
D
Front and rear axle boots
Battery
Engine Cylinder
Cylinder Base Fasteners
Engine mounts
l
General Lubrication
Shift Linkage
l
Front Suspension
l
Rear Suspension
D
Steering
Front Prop Shaft, Shaft Yoke,
l
Boots
Rear Prop Shaft, Shaft Yoke,
l
Boots
Throttle Cable/
D
pedal
D
Drive belt
Coolant strength
Cooling System hoses
l
Rear Gear case Oil
l
Front Gear case Oil
l
Oil Filter
l
Engine Oil-Level/Change
Parking Brake
D
Adjustment
D
Fuel System
D
Wheels bearings
l
Radiator
D
Fuel Filter
Hours
10 hrs
10 hrs
20 hrs
Head and
25 hrs
25 hrs
50 hrs
50 hrs
50 hrs
50 hrs
50 hrs
50 hrs
50 hrs
Accelerator
50 hrs
50 hrs
50 hrs
50 hrs
100 hrs
100 hrs
Every
100 hrs
Every
100 hrs
Cable
100 hrs
100 hrs
100 hrs
100 hrs
100 hrs
When Remarks
Weekly Inspect ; Replace if necessary
Inspect periodically
Monthly
Monthly Check
damage, replace if necessary
Monthly Check/clean Terminals
Inspect (re-torque
3 months
service only)
3 months Inspect
Lubricate all grease fittings,
3 months
pivots, cables, etc.
6 months Inspect, adjust
6 months Inspect, lubricate, tighten fasteners
6 months Inspect, lubricate, tighten fasteners
Check operation and for looseness,
6 months worn, damage, binding feeling / Adjust,
repair, Replace if necessary.
Inspect, lubricate, replace if necessary
6 months
Inspect, lubricate, replace if necessary
6 months
Inspect, adjust, lubricate, replace if
6 months
necessary
6 months Inspect, replace if necessary
6 months Inspect strength seasonally
6 months Inspect/replace if necessary
Monthly Check monthly and change annually
Monthly Check monthly and change annually
Oil filter replacement at the above
2000 km or 6
intervals, should be done together with
months
the engine oil change
Check Level Daily; Break-in Service at
2000 km or
200Km (1month). Change oil more often
6months
in cold weather use.
Inspect, adjust tension as needed
6 months
Check for leaks at tank cap, lines, fuel
12 months
pump, replace fuel lines annually
12 months Inspect, replace if necessary
12 months Inspect, clean
12 months Replace annually
CHAPTER 2
LH800U-2D SERVICE
for Axle boots, looseness,
required
MAINTENANCE PAGE. 2-
at first
3