Perkins 4016-E61TRS User Handbook Manual page 7

1
4016-E61TRS
Start-up
l When working on the engine always ensure that the battery has been disconnected, and that any other
means of accidental start-up has been disabled.
l Never start the engine with the governor linkage disconnected.
l Do not hold the stop lever in the run position when starting the engine.
l Always hold the stop lever in the stop position when cranking only.
Electrical equipment
l Always check that electrics are earthed to local safety standards.
l Always disconnect the electrical supply to the jacket water heater (if fitted) before working on the engine.
l Take care to prevent any danger of electric shock.
l Never re-adjust the settings of electronic equipment without reference to the Workshop Manual.
Freezing or heating components
l Always use heat resistant gloves and use the correct handling equipment.
Exhaust system
l Check the system for leaks.
l Ensure that the engine room is correctly ventilated.
l Check that all the guards are fitted.
l Check that the pipework allows the exhaust gas to escape upwards.
l Check that the pipework is supported.
Stopping the engine
1 Disengage the engine load.
2 Run the engine on NO LOAD for 15 minutes before stopping.
Note: This will allow the circulating lubricating oil to dissipate heat from the bearings, pistons, etc. It will also
allow the turbochargers, which run at a very high speed, to slow down while there is still oil flow through the
bearings.
Ensure that the engine is stopped before performing any of the following operations:
l Changing the lubricating oil.
l Filling or topping up the cooling system.
l Beginning any repair work on the engine.
l Adjusting belts (where fitted).
l Adjusting bridge pieces / valve clearance.
l Changing spark plugs.
l Changing air or oil filters.
l Tightening any fixing bolts.
Flammable fluids
l Ensure that these are never stored near the engine.
l Ensure that they are never used near a naked light.
User's Handbook, TSL 4230, Issue 4 3
This document has been printed from SPI². Not for Resale