General Maintenance And Lubrication Chart - Yamaha FX10X 2008 Service Manual

GENERAL MAINTENANCE AND LUBRICATION CHART

GENERAL MAINTENANCE AND LUBRICATION CHART
ITEM
Engine oil
∗ Engine oil filter cartridge
∗ Cooling system
Primary and secondary
∗
clutches
∗ Drive chain
∗ Drive chain oil
∗ Brake and parking brake
Control cables
∗ Disc brake installation
∗ Slide runners
∗ Skis and ski runners
∗ Steering system
∗ Steering bearings
∗ Ski and front suspension
∗ Suspension component
Fittings and fasteners
∗ Battery
∗ It is recommended that these items be serviced by a Yamaha dealer.
NOTE:
Brake system:
• After disassembling the master cylinder or caliper cylinder, always change the brake fluid. Regularly check
the brake fluid level and add fluid if necessary.
• Replace the oil seals of the master cylinder and caliper cylinder every two years.
• Replace the brake hose every four years, or if cracked or damaged.
REMARKS
• Change (warm engine before draining)
• Replace.
• Check coolant level.
• Air bleed the cooling system if necessary.
• Check engagement and shift speed.
• Adjust if necessary.
• Inspect sheaves for wear and damage.
• Inspect weights/rollers and bushings for wear for primary.
• Inspect ramp shoes/bushings for wear for secondary.
• Replace if necessary.
• Lubricate with specified grease.
• Check chain slack.
• Adjust if necessary.
• Check oil level.
• Change.
• Adjust free play and/or replace pads if necessary.
• Change brake fluid.
• Make sure that operation is smooth.
• Lubricate if necessary.
• Check for slight free play.
• Lubricate shaft with specified grease as required.
• Check for wear and damage.
• Replace if necessary.
• Check for wear and damage.
• Replace if necessary.
• Check toe-out.
• Adjust if necessary.
• Check bearing assemblies for looseness.
• Lubricate with specified grease.
• Lubricate with specified grease.
• Lubricate with specified grease.
• Make sure that all nuts, bolts and screws are properly tightened.
• Tighten if necessary.
• Check condition.
• Charge if necessary.
2-2
INSP
ADJ
INITIAL EVERY
1 month or Seasonally
800 km or 4000 km
(500 mi) (2500 mi)
(40 hr) (200 hr)
Every
20000 km
(12000 mi)
Whenever operating elevation
is changed.
Initial at 500 km (300 mi) and
every 800 km (500 mi) thereaf-
ter.
See NOTE following this chart.
Every 1600 km (1000 mi)
2