Adjustable Fendered Side Guard (Aluminum); Mounting - TiLite TRA AERO T Owner's Manual

CHAPTER 6: SIDE GUARDS
ADJUSTABLE FENDERED SIDE GUARD

Mounting

Tools Needed:
• 5/64" Allen Wrench
• 5/32" Allen Wrench
• 3/16" Allen Wrench
Note: You may need to adjust the Tension Adjustable Seat Sling to gain access to the seat tube placement you
desire. If this is necessary, see "Adjusting the Tension" on pages 7-3 and 7-4.
1. Insert Allen screw #1 through the conical washer, the slot in the rear cam, spacer and into the back mount. Do
not tighten. See Figure 6-6.
2. Insert Allen screw #2 through the conical washer, the slot in the front cam and into the top hole of the outer clamp.
Do not tighten.
3. Insert Allen screw #3 through the washer, inner clamp and into the outer clamp. Do not tighten.
4. Loosen but do not remove the eight Button Head Cap screws (four in each cam).
5. Adjust the side guard to the desired position, rotating the cams as needed and allowing the Allen screws to slide
within the cam slots.
6. Once the desired side guard position has been achieved, tighten the eight Button Head Cap screws (four on each
cam) using the 5/64" Allen wrench.
7. Using the 5/32" Allen wrench, securely tighten Allen screw #1.
8. Securely tighten Allen screw #2 in place using the 5/32" Allen wrench.
9. Securely tighten Allen screw #3 in place using the 3/16" Allen wrench.
I WARNING
The threads on the Button Head Cap screws and Allen screws #1 and #2 have been treated with Vibra-TITE® VC-3,
a locking and sealing coating, to reduce the possibility that they will become loose. You should be able to adjust the
cams and/or sideguards approximately four times without reapplying the coating to these screws. If you repeatedly
adjust the cams or remove the sideguard, TiLite requires that you reapply Vibra-TITE® VC-3 after every fourth
adjustment. If you ignore this Warning, you could fall, tip over or lose control of the wheelchair and seriously injure
yourself or others or damage the wheelchair.
Aero T/TRA Owner's Manual
Figure 6-5
Fendered Carbon Fiber Side Guard
Stabilizer
Tab
Side Guard
Mount
(Aluminum)
6-4
Bracket
Clamp
OM_Aero T_TRA_0414RevB