General Instructions; Storage; Operating; Cleaning - Weber Vieluxe 27 Built-In Grill Owner's Manual

GENERAL INSTRUCTIONS

• These instructions will give you the minimum requirements for assembling your Vieluxe
instructions carefully before using your Vieluxe
• Not for use by children.
• If there are local codes that apply to gas grills, you will have to conform to them. If there are no local
codes, you must conform to the latest edition of the National Fuel Gas Code: ANSI Z 223.1/NFPA 54.
• This regulator is set for 10.5 inches of water column (pressure).
• This Vieluxe ® grill is designed for use with liquid propane (LP) gas only. Do not use with natural (piped in city) gas.
The valves, orifices, hose and regulator are for LP gas only.
• Do not use with charcoal fuel.
• Check that the area under the control panel and the bottom tray are free from debris that might obstruct the flow
of combustion or ventilation air.

Storage

• The gas must be turned OFF at the gas supply when the Vieluxe

Operating

WARNING: Only use this grill outdoors in a well-ventilated area. Do not use in a garage, building,
breezeway or any other enclosed area.
WARNING: Never use your Vieluxe
WARNING: Your Vieluxe
WARNING: Do not use combustible materials within 26 inches of the top, bottom, back or sides of
the grill.
WARNING: The entire cooking box gets hot when in use. Do not leave unattended.
WARNING: Keep any electrical supply cord and the fuel supply hose away from any heated surface.
WARNING: Keep the cooking area clear of flammable vapors and liquids such as gasoline, alcohol, etc.,
and combustible materials.
WARNING: Never store an extra LP cylinder under or near the Vieluxe
WARNING: Keep the ventilation openings of the cylinder enclosure free and clear of debris.
WARNING: Turn off the gas at the LP gas supply cylinder when the outdoor cooking gas appliance is not
in use.
WARNING: Never store an outdoor cooking gas appliance indoors unless the LP cylinder is disconnected
and removed from the outdoor cooking gas appliance.
WARNING: LP Cylinders must be stored outdoors out of the reach of children and must not be stored in a
building, garage, or any other enclosed area.
WARNING: The LP pressure regulator and hose assembly supplied with the outdoor cooking gas
appliance must be used. Replacement LP pressure regulators and hoses must be obtained from
Weber-Stephen Product Co..

Cleaning

WARNING: Turn your Vieluxe
CAUTION: Do not clean your Flavorizer
replacement cooking grates and Flavorizer
Outside surfaces - Use a warm soapy water solution to clean, then rinse with water.
CAUTION: Do not use oven cleaner, abrasive cleansers (kitchen cleansers) cleaners that contain citrus
products, or abrasive cleaning pads on barbecue or cart surfaces.
Slide out Bottom tray - Remove excess grease, then wash with warm soapy water, then rinse
Flavorizer ® bars and Cooking grates - Clean with a suitable brass bristle brush. As needed, remove from grill and
wash with warm soapy water, then rinse with water.
Catch pan - You can line the catch pan with aluminum foil. To clean the catch pan, wash with warm soapy water,
then rinse.
Thermometer - Wipe with warm soapy water; clean with plastic scrub ball. Do not put in dishwasher or submerge in
water.
Inside cooking module - Brush any debris off of burner tubes. DO NOT ENLARGE BURNER PORTS
(OPENINGS). Wash inside of cooking box with warm soapy water and a water rinse.
Inside Lid - While lid is warm, wipe inside with paper towel to prevent grease build-up. Flaking built-up grease
resembles paint flakes.
Stainless steel surfaces - Wash with a soft cloth and a soap and water solution. Be careful to scrub with the grain
direction of the stainless steel.
Do not use cleaners that contain acid, mineral spirits or xylene. Rinse well after cleaning.
® grill. Improper assembly can be dangerous.
® grill under an unprotected combustible roof or overhang.
® grill is not intended to be installed in or on recreational vehicles and/or boats.
® gas grill OFF and wait for it to cool before cleaning.
® bars or cooking grates in a self-cleaning oven. For availability of
® bars contact Vieluxe
® grill. Please read the
® grill is not in use.
® grill.
® Customer Service at 1-866-VIELUXE.
5