Table of Contents
Advertisement
PRECAUTIONS FOR MAINTENANCE
•
Covering swollen in places.
•
Twisted or crushed movable portion.
•
Foreign material embedded in covering.
PRECAUTIONS FOR NOISE
When performing maintenance of the engine and you are exposed to noise for long periods of time, wear ear
covers or ear plugs while working.
If the noise is too loud, it may cause temporary or permanent hearing problems.
HANDLE ACCUMULATOR AND GAS SPRING
This machine is equipped with an accumulator. For a while after the engine has been stopped, if the multifunc-
tion mono-lever is operated in LOWER direction while the starting switch key is at ON position, the work equip-
ment goes down with its own weight.
After stopping the engine, turn the work equipment lock switch to LOCK position and the parking brake switch to
ON (operation) position.
The accumulator and gas spring are charged with high-pressure nitrogen gas. If the accumulator is handled
mistakenly, it may cause an explosion. It is dangerous and may cause serious personal injury or death. Always
observe the following.
•
Do not disassemble.
•
Do not bring it near flame or dispose of it in fire.
•
Do not make holes in it, weld it, nor use a cutting torch.
•
Do not hit or roll the accumulator, or subject it to any im-
pact.
•
When disposing of the accumulator, the gas must be re-
leased. Ask your Komatsu distributor to perform this work.
PRECAUTIONS FOR COMPRESSED AIR
•
When performing cleaning with compressed air, there is a hazard of serious personal injury or death
caused by flying dust or particles.
•
When using compressed air to clean the filter element or radiator, wear protective eyeglasses, anti-dust
mask, gloves, and other protective equipment.
MAINTENANCE OF AIR CONDITIONER
If air conditioner refrigerant gets into your eyes, it may cause loss of sight; if it contacts your skin, it may cause
frostbite. Never loosen any parts of the cooling circuit.
CHEMICAL HAZARD
During maintenance or dismantling operations, where there is the risk of contact with hazardous chemical sub-
stances, relevant safety precautions should be taken.
If any doubt exists, contact your Komatsu distributor.
PRECAUTIONS FOR DISPOSING OF WASTE MATERIALS
To prevent pollution, pay full attention to the way to dispose of waste materials.
2-40
SAFETY
Advertisement
Chapters
Table of Contents
