Fuel System Maintenance; Replacing The Fuel Filter; Electrical System Maintenance; Servicing The Battery - Toro Spray Master Series Operator's Manual

Fuel System
Maintenance

Replacing the Fuel Filter

Service Interval: Every 400 hours
1. Inboard of the right spray tank, squeeze the tabs
on the clamps and slide the clamps away from
the fuel filter (Figure
Figure 80
1. Fuel line
2. Fuel filter
2. Rotate and pull the fuel lines off the fuel filter
(Figure 80).
Check the fuel lines for cracks or leaks; repair,
if necessary.
3. Replace the fuel filter
Important:
Align the fuel filter with the
arrow pointing toward the engine fuel pump.
4. Secure the fuel lines to the filter using the
clamps (Figure 80).
80).
3. Clamp
(Figure 80).
Electrical System
Maintenance

Servicing the Battery

Service Interval: Monthly
Always keep the battery clean and fully charged. Use
a paper towel to clean the battery case. If the battery
terminals are corroded, clean them with a solution of
4 parts water and 1 part baking soda. Apply a light
coating of grease to the battery terminals to prevent
corrosion.
Voltage: 12 V
DANGER
Charging or jump starting the battery may
produce explosive gases. Battery gases can
g313098
explode causing serious injury.
• Keep sparks, flames, or cigarettes away
from battery.
• Ventilate when charging or using battery in
an enclosed space.
• Ensure that the venting path of battery is
always open once the battery is filled with
acid.
• Do not lean over the batteries.
• Always shield eyes and face from battery.
DANGER
Battery electrolyte contains sulfuric acid,
g312580
which is poisonous and can cause severe
burns. Swallowing electrolyte can be fatal or
if it touches skin can cause severe burns.
• Wear eye protection to shield your eyes
and rubber gloves to protect your skin and
clothing when handling electrolyte.
• Do not swallow electrolyte.
• In the event of an accident, flush with water
and call a doctor immediately.
59