Hoshizaki KM-340MAH Manual page 14

Ice Machine
The icemaker must be cleaned & sanitized at least once a year.
Cleaning Prep:
1 Remove the Front Panel, move the R
OFF. After 3 min., move the
replace the Front Panel.
After 3 min., remove the Front Panel, move the A
2
control switch to OFF. This removes the cubes from
the evaporator.
Remove all ice from the dispenser unit/ice storage bin
3 R
ATTENTION! IF ON DISPENSER, turn off the dispenser
power supply after dispensing all the ice.
Cleaning:
Front of Icemaker
(KML-351MAH shown)
CONTROL SWITCH
SERVICE SWITCH
R Remove the Front Panel, move the
4
DRAIN. Move control switch
the Front Panel.
A After 2 minutes, remove the Front Panel, move the
5
control switch to OFF.
D Dilute Hoshizaki Scale Away with warm water (see Table below).
6
R Remove the Front Insulation Panel and pour cleaning solution
into the water tank. Replace the Front Insulation Panel.
#51007 | 9.16.2016
Page 14
Cleaning & Sanitizing
control switch to
control switch to ICE, then
service switch to
to SERVICE. Replace
continued on the back...
Tech Support: 1.800.233.1940
3
min.
3
min.
.
Top
Side
After 2 min.
KML-250MAH, MWH
KML-351MAH, MWH
KML-451MAH, MWH
KML-631MAH, MWH, MRH
ATTENTION!
Do not leave icemaker
unattended when panels are off
AMMONIA
Cleaners
Sanitizing:
Dilute 5.25% chlorine
bleach* with warm water
(see Table below)
KML-451 and smaller
Bleach 1 fl. oz (30 ml)
Warm Water 2 gal. (7.6 l)
KML-631
Bleach
1.25 fl. oz (37 ml)
Warm Water 2.5 gal. (9.5 l)
* Use bleach without additives.
Remove the front insulation
panel
Pour the sanitizing solution
into the water tank
Replace the front insulation
panel
Move service switch to
WASH and control switch
SERVICE, replace the front
panel
After 15 minutes, remove
front panel
Move service switch to DRAIN,
replace the front panel
After 2 minutes, remove
front panel
Move control switch to OFF
15
n 16
17
to
18