Range Test - PEUGEOT E1A Workshop Manual

Range test:

Under the following conditions:
Scooter charged 100%, run it within a maximum of 8 hours after the end of charging
The route should be covered without interruption, on flat roads with a minimum of stops and until the
reserve light comes on (the reserve you to cover another 5 km)
Over 20 km, check:
Tyre
pressures adjustment:
20 mm play
2.5 bar
on brake lever
Carry out a
range check
Reproductions or translations, even parrtial, are forbidden without the written consent of Peugeot Motocycles
TROUBLESHOOTING LOGIC DIAGRAM
Ranged stated by customer
Brake Electrolyte
level in cells
If level is
incorrect, carry
out battery
maintenance
If range is still low, discharge the 3 cells using the
discharge apparatus and compare the discharge times of
If a cell has a discharge time far below that of the others
Under 20 km with motor cut-out,
check:
Electrolyte
leak on one
of the cells
If the difference in
voltage is under
0.8 V, the battery
is OK
Carry out a range check.
each cell.
change it.
With power gauge under
25 % and the cells
disconnected,
check the voltage of each
cell.
The difference in voltage
between each cell should
not be over 0.8 V.
If the difference in
voltage is over 0.8
V, the weakest
battery must be
changed
Page: 28