Yamaha SXV70SJ Supplementary Service Manual page 135

Item
Brake and parking brake
Drive chain oil
Drive chain
Skis and ski runners
Steering system
Strap (MM700)
Lights
Battery
(VX700DX/VT700)
Primary and secondary
clutches
Steering column bearing
Ski and front suspension
Suspension component
Parking brake cable end
and lever end/throttle cable
end
Shroud latches
Fittings and fasteners
Tool kit and recommended
equipment
NOTE:
Brake fluid replacement:
1. When disassembling the master cylinder or caliper cylinder, replace the brake fluid. Normally check the brake
fluid level and add the fluid as required.
2. On the inner parts of the master cylinder and caliper cylinder, replace the oil seals every two years.
3. Replace the brake hoses every four years, or if cracked or damaged.
PERIODIC MAINTENANCE TABLE
Remarks
Check operation and fluid leakage.
Adjust free play and/or replace pads if necessary.
Replace brake fluid.
Check oil level.
Replace.
Check deflection.
Adjust if necessary.
Check for wear and damage.
Replace if necessary.
Check operation.
Adjust toe-out if necessary.
Check for damage.
Replace if necessary.
Check operation.
Replace bulbs if necessary.
Check fluid level.
Add only distilled water if necessary.
Check specific gravity and breather hose operation.
Charge/correct if necessary.
Check engagement and shift speed.
Adjust if necessary.
Inspect sheaves for wear/damege.
Inspect weights/rollers and bushings for wear-
for primary.
Inspect ramp shoes/bushings for wear-for sec-
ondary.
Replace if necessary.
Lubricate with specified grease.
Lubricate with specified grease.
Lubricate with specified grease.
Lubricate with specified grease.
Lubricate with specified grease.
Check cable damage.
Replace if necessary.
Make sure that the shroud latches are hooked.
Check tightness.
Repair if necessary.
Check proper placement.
Pre-
operation
check
(Daily)
Initial at 500 km (300 mi) and every 800 km
(500 mi) thereafter.
Whenever operating elevation is changed.
2-2
INSP
ADJ
Every
Initial
1 month
Seasonally
or
or
800 km
3,200 km
(500 mi)
(2,000 mi)
(40 hr)
(160 hr)
See NOTE.