Introduction - Smeg GW1160 User Manual

1 INTRODUCTION

GW1160, GW4060 series – professional glassware washing machines, laboratory glassware washers (GW – glassware
washer).
Smeg GW1160, GW4060 family products comply with all the prerequisites of the relevant safety regulations and the
standards in force for electrical equipment.
This manual describes two products series.
• GW4060 Series: laboratory glassware washers, 60cm, equipped with forced air drying system.
• GW1160 Series, laboratory glassware washers, 60cm, without drying system.
The diagrams and images contained in this document refer to the most complete series, GW4060.
For the GW1160 series the same considerations and procedures apply, unless otherwise specified.
The table below summarises the product's main characteristics. (For a full list of models and their configurations refer
to the "LIST OF MODELS" point below).
CONTROL
DOOR OPENING
DETERGENT DISPENSING
OPTIONAL DETERGENT DISPENSING
CONTROL OF DETERGENT DISPENSING
DETERGENT CAN LEVEL CONTROL
TEMPERATURE CONTROL
STEAM CONDENSER
DRYING SYSTEM
ABSOLUTE DRYING FILTER
RAILS IN CHAMBER FOR TOP BASKET
WATER INTAKE CONNECTIONS
PRESET PROGRAMS
COMMUNICATION
1
The WD-TRACE software enables the user to communicate with SMEG "WD" and "GW" instrument and glassware
washers.
Once the connection has been made, the user can:
- Keep a record of the disinfection cycles performed.
- Monitor the appliance's status.
- Download new versions of the appliance's software.
- Modify programs.
- Save the appliance parameter setup.
User Manual
ELECTRONIC with MICROPROCESSOR
(with Time and Date functions)
Powder detergent dispenser DD (integral in inner door)
and peristaltic pump P2
Single Platinum PT probe (TL1)
On special models with suffix "C"
(GW1160 Cxx, GW4060 Cxx)
Yes, forced air (only on GW4060 series)
Optional (only on GW4060 series)
Mains and Demineralised
Specific LABORATORY programs, TOTAL OF 16
PROGRAMS of which 6 are CUSTOM (customisable using
SMEG WD-TRACE software
in the product's basic outfit)
RS232 serial (For PC or Printer)
GW1160 - GW4060 Series
GW – basic model
Automatic
peristaltic pump P1
peristaltic pump P3
Optional
Optional
Yes
1
. The software is not included
Page 6 - 75