1. Manuals
  2. Brands
  3. Harman Manuals
  4. Indoor Fireplace
  5. 300i
  6. Owner's manual

Harman 300i Owner's Manual

Woodburning fireplace insert
Hide thumbs Also See for 300i:
Table of Contents

Advertisement

Quick Links

For Installation In Masonry Fireplace Only
Owner's Manual

Installation and Operation

Model:
300i Woodburning Fireplace Insert
contact your local dealer with questions on installation,
operation or service.
please read this entire manual before you install and use your new wood burning insert. failure to follow instructions
may result in property damage, bodily injury, or even death.
•
Important operating and
maintenance instructions
included.
!
please read this entire manual before
installation and use of this wood-burning
room heater.
failure to follow these instructions could
result in property damage, bodily injury
or even death.
• do not store or use gasoline or other flammable
vapors and liquids in the vicinity of this or any other
appliance.
• do not overfire - If any external part starts to glow,
you are overfiring. close air controls. overfiring will
void your warranty.
• comply with all minimum clearances to combustibles
as specified. failure to comply may cause a house
fire.
!
CHECk bUILDINg CODES pRIOR TO INSTALLATION.
• InstallatIon MUst coMply wIth local, regIonal,
STATE AND NATIONAL CODES AND REgULATIONS.
• consUlt local bUIldIng, fIre offIcIals or
A U T H O R I T I E S H Av I N g j U R I S D I C T I O N A b O U T
restrIctIons, InstallatIon InspectIon, and
pERMITS.
To obtain a French translation of this manual, please contact your dealer or visit www.harmanstoves.com
Pour obtenir une traduction française de ce manuel, s'il vous plaît contacter votre revendeur ou visitez www.harmanstoves.com
1
DO NOT DISCARD THIS MANUAL
•
Read, understand and
follow these instructions
for safe installation and
operation.
WARNING
CAUTION
Harman® • 300i Wood Insert Owner's Manual_R13 • 2010 -___ • 04/15
NOTICE
•
Leave this manual with
party responsible for use
and operation.
hot, will cause burns.
• do not touch glass until it is cooled
• never allow children to touch glass
• Keep children away
• carefUlly sUpervIse children in same room
as fireplace.
• alert children and adults to hazards of high
temperatures.
high temperatures may ignite clothing or other
flammable materials.
• Keep clothing, furniture, draperies and other
flammable materials away.
tested and approved for Use wIth dry,
seasoned cordwood only. do not bUrn wet
or green wood. bUrnIng any other type of
fUel wIll voId yoUr warranty.
Harman 300i Wood Insert
Wood Stove
Use & Care Video
!
WARNING
HOT SURFACES!
glass and other surfaces
are hot during operation
AND cool down.
!
CAUTION
3-90-300101

Advertisement

Table of Contents
loading

Related Manuals for Harman 300i

Summary of Contents for Harman 300i

  • Page 1: Installation And Operation

    To obtain a French translation of this manual, please contact your dealer or visit www.harmanstoves.com Pour obtenir une traduction française de ce manuel, s’il vous plaît contacter votre revendeur ou visitez www.harmanstoves.com Harman® • 300i Wood Insert Owner’s Manual_R13 • 2010 -___ • 04/15 3-90-300101...
  • Page 2 Date of Manufacture / Date de fabrication: 2014 2015 2016 JAN FEB MAR APR MAY JUN JUL AUG SEP OCT NOV DEC Manufactured by/Fabriqué par: Hearth and Home Technologies P.N. 3-90-300100 Rev C Harman® • 300i Wood Insert Owner’s Manual_R13 • 2010 -___ • 04/15 3-90-300101...

  • Page 3: Table Of Contents

    • CAUTION! Indicates a hazardous situation which, if not avoided, could result in minor or moderate injury. • NOTICE: Used to address practices not related to personal injury. Harman® • 300i Wood Insert Owner’s Manual_R13 • 2010 -___ • 04/15 3-90-300101...

  • Page 4: Product Specifications And Safety Information

    DAMAgE TO THE STOvE AND COULD RESULT IN sUch as gasolIne, naptha, or engIne oIl. a hoUse fIre. Use only approved fUels and follow only these operatIon gUIdelInes. WARNING never Use gasolIne, gasolIne-type lantern fUel, Kerosene, charcoal lIghter flUId, or SIMILAR LIQUIDS TO START OR 'FRESHEN Up' A FIRE IN THIS HEATER. kEEp ALL SUCH LIQUIDS WELL away froM the heater, whIle In Use. Harman® • 300i Wood Insert Owner’s Manual_R13 • 2010 -___ • 04/15 3-90-300101...

  • Page 5: Fire Safety

    Serious damage could occur. fIre May resUlt. for yoUr safety, follow INSTALLATION DIRECTIONS. CONTACT LOCAL bUILDINg OR FIRE OFFICIALS AbOUT RESTRICTIONS AND INSTALLATION INSpECTION REQUIREMENTS IN yoUr area. Harman® • 300i Wood Insert Owner’s Manual_R13 • 2010 -___ • 04/15 3-90-300101...

  • Page 6: Component Location

    Andirons Surround Side 17-5/8" appliance dimension diagram 447mm Dimensions are actual appliance dimensions. Use for reference only. 41" / 1042mm 30" 762mm 5-1/8" 129mm 40" / 1016mm 28-1/2" 724mm Harman® • 300i Wood Insert Owner’s Manual_R13 • 2010 -___ • 04/15 3-90-300101...

  • Page 7: Installation

    25-1/2" (648mm) or more, from the fireplace facing, no additional floor protection is needed. If the hearth depth is less than 25-1/2" (648mm), floor protection must be installed. Harman® • 300i Wood Insert Owner’s Manual_R13 • 2010 -___ • 04/15 3-90-300101...

  • Page 8: Masonry Fireplace Requirements

    Follow manufacturer's guidelines for attaching and securing each venting component. do not connect to any aIr dIstrIbUtIon dUct or systeM Harman® • 300i Wood Insert Owner’s Manual_R13 • 2010 -___ • 04/15 3-90-300101...

  • Page 9: Clearances

    29-5/8" (752mm) WARNING DO NOT INSTALL IN SLEEpINg ROOM. WARNING do not connect thIs UnIt to a chIMney flUe SERvINg ANOTHER AppLIANCE. CAUTION MAkESHIFT COMpROMISES MADE DURINg InstallatIon or alterIng any sUpplIed part or coMponent May present a safety hazard AND ARE ExCLUDED FROM THE pRODUCT warranty coverages. Harman® • 300i Wood Insert Owner’s Manual_R13 • 2010 -___ • 04/15 3-90-300101...

  • Page 10: Flue Liner

    The hooks on back will hold down on the collar when in place. Etched lines mark the face of the fireplace opening. Two bolts secure the flue adapter to the insert. Harman® • 300i Wood Insert Owner’s Manual_R13 • 2010 -___ • 04/15 3-90-300101...

  • Page 11: Slide Assist Rollers

    It is up to you if you want to raise the roller and lock it in to the disengaged position. Lower Base Cover Leveling bolt Front Roller Ready position Roller Locked position Harman® • 300i Wood Insert Owner’s Manual_R13 • 2010 -___ • 04/15 3-90-300101...

  • Page 12: Distribution Blower Installation

    Speed 3 Male 6 Inch Green Control Disconnects Ground Wire Grounded to Stove Body 120 V AC / 60 Hz, 110 Watt , 1.0 Amp Maximum 3-90-300141 Harman® • 300i Wood Insert Owner’s Manual_R13 • 2010 -___ • 04/15 3-90-300101...

  • Page 13: Surround Installation

    (Tek) screw at the bottom. The Bottom Hole is Threaded Next, install the top panel by inserting the four (4) studs through the holes in the fin on the insert. Secure with the provided nuts and a 11/32" nut driver. Harman® • 300i Wood Insert Owner’s Manual_R13 • 2010 -___ • 04/15 3-90-300101...

  • Page 14: Operations

    "Firedome" combustion package where it combines with the heated exhaust gases. This re- WARNING burning of the smoke is known as "Secondary Combustion". never build a fire directly against the glass. always keep the fuel load behind the andirons. Harman® • 300i Wood Insert Owner’s Manual_R13 • 2010 -___ • 04/15 3-90-300101...

  • Page 15: Damper Bypass Operation

    Medium-high position. note: the bypass damper must be open for smokeless loading. air control shown in the full damper open damper closed open position which is to be used only for start-up and refueling Harman® • 300i Wood Insert Owner’s Manual_R13 • 2010 -___ • 04/15 3-90-300101...

  • Page 16: Overfiring

    Have your chimney professionally cleaned and inspected before resuming burning in your insert. Harman® • 300i Wood Insert Owner’s Manual_R13 • 2010 -___ • 04/15 3-90-300101...

  • Page 17: Building & Maintaining A Fire

    Operating As A Fireplace Begin with the bypass damper open, and the air control The 300i is tested and approved to be burned with the front lever at the maximum setting, all the way to the right. load door open and the damper open. In this mode of Start with a bed of crumpled paper and kindling sized operation you get a true fire sound as well as appearance.

  • Page 18: Maintenance

    In any case, • Do NOT use abrasive cleaners. dry thoroughly before relighting your insert. • Inspect gasket, replace if necessary. Harman® • 300i Wood Insert Owner’s Manual_R13 • 2010 -___ • 04/15 3-90-300101...

  • Page 19: Gaskets

    You should, however, keep the air inlets and the motors and will void the warranty of the firedome combustion fan blades free of dust and pet hair. system. Harman® • 300i Wood Insert Owner’s Manual_R13 • 2010 -___ • 04/15 3-90-300101...

  • Page 20: Service Parts List

    Beginning Manufacturing Date: Sept. 2010 Wood Insert Ending Manufacturing Date: Active 1-70-300100-1 (Black), Ending Manufacturing Date: June 2011 1-70-300100-2 (Charcoal), 1-70-300100-3 (Golden re)) Part number list on following page. 4/15 Harman® • 300i Wood Insert Owner’s Manual_R13 • 2010 -___ • 04/15 3-90-300101...
  • Page 21 Black 1-00-300130-1 Standard Wing 1-00-300130-2 No longer available 1-00-300130-3 No longer available Hardware Pack 1-00-300 Lower Base Cover 2-00-300125P Additional service part numbers appear on following page. Harman® • 300i Wood Insert Owner’s Manual_R13 • 2010 -___ • 04/15 3-90-300101...

  • Page 22: Firebox Assembly

    Right Plate Assembly w/Gasket 1-10-249118A Gasket, 1/4 " Round White Rope 10 Ft 1-00-11862 Srew-HCS5/16-18 X 1-1/4 Pkg of 50 3-30-1129-50 Additional service part numbers appear on following page. Harman® • 300i Wood Insert Owner’s Manual_R13 • 2010 -___ • 04/15 3-90-300101...
  • Page 23 Post 008700510 3-42-19905 Touch up Paint - Charcoal 3-42-6201 No longer available Touch up Paint - Golden re 3-42-6230 No longer available Wire, Hi-temp 12 Ft 1-00-94733 Harman® • 300i Wood Insert Owner’s Manual_R13 • 2010 -___ • 04/15 3-90-300101...

  • Page 24: Warranty

    Firebox and heat exchanger Lifetime All replacement parts 90 Days beyond warranty period See conditions, exclusions, and limitations on next page. 4021-645F 02-18-13 Page 1 of 2 Harman® • 300i Wood Insert Owner’s Manual_R13 • 2010 -___ • 04/15 3-90-300101...
  • Page 25 THE EXTENT PROVIDED BY LAW, HHT MAKES NO EXPRESS WARRANTIES OTHER THAN THE WARRANTY SPECIFIED HEREIN. THE DURATION OF ANY IMPLIED WARRANTY IS LIMITED TO DURATION OF THE EXPRESSED WARRANTY SPECIFIED ABOVE. 4021-645F 02-18-13 Page 2 of 2 Harman® • 300i Wood Insert Owner’s Manual_R13 • 2010 -___ • 04/15 3-90-300101...

  • Page 26: Contact Information

    Printed in U.S.A. Harman® • 300i Wood Insert Owner’s Manual_R13 • 2010 -___ • 04/15 3-90-300101...

Table of Contents