Nameplate And Decals Assy - MULTIQUIP DA7000SSA2GH Operation And Parts Manual

3
5
Before connecting this generator to any building's
OPERATING PROCEDURE electrical system, a licensed electrician must install
an isolation [transfer] switch.
MULTIQUIP WhisperWatt
AC Generator
Serious injury or death may result without this
1. Check the oil level.
transfer switch.
9. Let the engine idle for more than 5 minutes
2. Check the water level.
3. Check the fuel level. with the Idle Control switch in "ON" position.
10. Check the engine for abnormal vibrations noise
4. T urn the Idle Control switch to "ON."
and oil leakage.
5. Insert the key into the Starter Switch.
11. T urn the Idle Control switch to either "ON" or
6. T urn the key to "RUN". The Charge
"OFF" for full engine operation.
Warning lamp and the Oil Pressure Warning lamp
12. After generating let the engine run for 5 minutes
should be lit.
with the Idle Control switch in the "ON" position.
7. Turn the key to "HEAT." When the preheat lamp
NEVER STOP THE ENGINE SUDDENLY EXCEPT
lights turn the key to "START" to start the engine.
IN AN EMERGENCY.
AVOID HIGH SPEEDS IMMEDIATELY AFTER
13. Stop the engine by turning the key in the
STARTING.
Starter Switch to "STOP" and remove the key.
8. When the engine starts, the Oil Pressure
Alarm lamp should go out. A555000103
24 FUSE PULLY
F6
F5 15A
WARNING
F4
5A
To avoid injury,
you MUST read
F3 5A
and understand
37
operator's manual
F2 5A
before using this
machine.
This machine to F1 30A
be operated by
quali ed
personnel only.
Ask for training
as needed.
P/N 35137
ALL RECEPTECALES
34
G.F.C.I. PROTECTED
A9210 0260
1 30A 30A
20A 50A
120V 120V/240V
AC POWER OUTPUT
A55200000A
36
120V 120V 120V/240V
for for for
20A 30A
DANGER
Using a generator indoors CAN KILL
YOU IN MINUTES
Generator exhaust contains carbon monoxide. This is
a posion you cannot see or smell
GA-2.9 R 2900 20 A V 12 0
20 A 20 A 120V AC CIRCUI BREAKE T R
GA-2.9 R 2900 12 0 V GA-2.9 R 2900 12 0 V ON
120V AC CIRCUI T BREAKER 120V R BREAKE T AC CIRCUI OF F
OF F ON ON OF F
Only use OUTSIDE and
NEVER use inside a home
far away from windows,
or garage, even if doors
doors, and vents.
and windows are open
Avoid other generator hazards.
READ MANUAL BEFORE USE .
DANGER
THE POSSIBILITY EXISTS OF ELECTROCUTION IF
GENERATOR/WELDER IS NOT PROPERLY GROUNDED.
ALWAYS CONNECT EARTH GROUND (GROUND
ROD) TO GENERATOR G.F.C.I. GROUND TERMINAL.
GROUND
CABL E G E
N E
G R R AT
#8 MINIMU M O U
N D O R
LU
G
G. F. C. I
GROUND RO D
GROUND
STUD FOR EART H
GROUND
CONNECT TO
BUILDIN G
GROUND
(OPTION)
31
FOR FURTHER GROUNDING
INSTRUCTIONS, READ MANUAL
8 FT . MINIMU M
REFERENCE
NEC 250-52(C)
D93110000
FRONT VIEW
22
WARNING
30
HOT COOLANT can cause
severe burns.
DO NOT remove cap if
radiator is hot.
38
DECAL
KIT
FUEL COCK
OFF
ON
PAGE 62 — DA7000SSA2/SSA2GH GENERATOR• OPERATION AND PARTS MANUAL — REV. #0 (03/26/15)
CHECK DAILY
1. Radiator water level.
WARNING!
2. Reserve tank water level.
(Important) Not more than
a 50/50 Anti-Freeze/Water
mixture is recommended.
3. Engine oil level.
30A
A9210 0350
32
Op era tion
spa rks tha
20
veg eta tion
A spa rk
The ope
age ncie s
to fire pre
33
21
GROUND
S-1123
13
FUEL DRAIN
S-3060
COOLING
WATER
S-3061
DCL183
16

NAMEPLATE AND DECALS ASSY.

CAUTION
WATER
4
COOLANT
LEVEL
H RESERVE
L TANK
DCL194
15
35
GROUND
G.F.C.I
for
S-3821
CIRCUIT BREAKER
S-3031
6
W A R N IN
G
of this equ
ipm ent ma
t can sta y cre ate
rt fire s aro
. und dry
arre sto r
ma y be req
rato r sho uire d.
uld con tac
for law s t loca l fire
or reg ula
ven tion req tion rela ting
uire me nts
.
M904 2 0000
S-2090
DANGER
EXPLOSIVE GASES
Cigarettes, flames or sparks could cause battery to explode. Always
shield eyes and face from battery. Do not charge or use booster cables
9
or adjust post connections without proper instruction and training.
KEEP VENT CAPS TIGHT AND LEVEL
POISON
CAUSES SEVERE BURNS
Contains sulfuric acid. Avoid contact with skin, eyes or clothing. In
event of accident flush with water and call a physician immediately.
KEEP OUT OF REACH OF CHILDREN
14
USE #2 DIESEL
USE ULTRA LOW SULFUR
FUEL ONLY
S-1408
19
17
WARNING
MOVING PARTS can cause
severe injury.
DO NOT operate with
doors open.
Stop engine before
servicing.
CAUTION:
DO NOT
OPERATE WITH
DOORS OPEN
FUEL COCK
OFF
25
ON
CAUTION
Before starting the engine, check that the oil
level is within the indicated operating range.
If the level is above the H
the L mark , it is important to correct before
operating to avoid damage to the engine.
12
COOLANT DRAIN
S-1404
11
OIL DRAIN
S-1403
CAUTION
26
CLEAN OR
REPLACE
PAPER ELEMENT
EVERY 100 HOURS
S-1406
8
S-2090
10
WARNING
Only operate machine in well ventilated
7
areas.
DO NOT inhale exhaust gases.
S-4984
Only qualified personnel should
DANGEROUS
install, use or service this
GAS
equipment.
18
2
SIDE VIEW
WARNING
DIESEL FUEL can cause 28
fire or explosion.
.
Stop engine before fueling.
.
Keep cigarettes, sparks
and flame away.
B90450000
27
DCL182
S-1409
2
OIL LEVEL
DIPSTICK
23
H
mark or below
L
WARNING
MOVING PARTS can cause
27
severe injury.
DO NOT operate with
doors open.
Stop engine before
servicing.
DCL182
CAUTION
can burn skin.
HOT PARTS
DO NOT touch until the
machine has sufficiently
cooled.
DCL181
29