Air Filter Housing Drain; Draining V-Belt Cover; Tires; Tire Tread Condition - Arctic Cat 2012 XC 4501 Operator's Manual

6. Put the element in a plastic bag; then pour in air filter oil and
work the oil into the element.
7. Squeeze the element to remove excess oil.
CAUTION
A torn air filter can cause damage to the ATV engine. Dirt and
dust may get inside the engine if the element is torn. Care-
fully examine the element for tears before and after cleaning
it. Replace the element with a new one if it is torn.
8. Clean any dirt or debris from
inside the air cleaner. Be sure
no dirt enters the carburetor.
9. Install the air filter and cover.
10. Connect the inlet boot and
tighten the clamp securely.
Air Filter Housing
Drain
Inspect the "duck bill" drain in front
of the main housing for debris and
for proper sealing.
Draining V-Belt
Cover

NOTE: If the ATV has been
driven through water, the V-belt
cover must be drained of any
water.
1. Place the ATV on a level surface.
2. Remove the drain bolt from the cover and allow the water to
drain out.
3. Shift the range lever to the neutral position; then start the engine.
4. Increase and decrease engine RPM several times to "blow out"
any water; then stop the engine.
5. Install the drain bolt and tighten securely.

NOTE: The V-belt and pulleys should be inspected every
500 miles and the belt replaced (if necessary).

Tires

Always use the size and type of tires as specified. Refer to the
Specifications chart for proper tire inflation pressure, and
always maintain proper tire inflation pressure.
KC0056B

Tire Tread Condition

The use of worn-out tires on an ATV is
very dangerous. A tire is considered to
be worn out when the depth of the tread
is less than 3 mm (1/8 in.). Be sure to
replace the tires before reaching this
minimum specification.
KC0056C
The use of worn-out tires is dangerous and can increase the
risk of an accident.

Tire Replacement

The ATV has low-pressure tubeless tires. Air is sealed by the contact
surfaces of the inner wheel rim and the tire bead. If either the inner
wheel rim or tire bead is damaged, air may leak. Be extremely careful
not to damage these areas when replacing tires.
KC0049A
! WARNING
! WARNING
0732-649
55