Winnebago Impulse User Manual
Winnebago Impulse User Manual

Winnebago Impulse User Manual

Impulse winnebago
Hide thumbs Also See for Impulse:
Table of Contents

Advertisement

About this Manual ............................................................................................................................ 1-1
Safety Messages Used in this Manual .............................................................................................. 1-1
Pre-Delivery Inspection .................................................................................................................... 1-2
Front Axle Tire Alignment ............................................................................................................... 1-2
Service and Assistance ...................................................................................................................... 1-2
Reporting Safety Defects .................................................................................................................. 1-2
Occupant and Cargo Carrying Capacity Label ................................................................................. 1-3
Vehicle Certification Label ............................................................................................................... 1-4
specifications and Capacities ............................................................................................................ 1-5
Owner and Vehicle Information ....................................................................................................... 1-6
2011 New Vehicle Limited Warranty ............................................................................................... 1-7
General Warnings ............................................................................................................................. 2-1
Driving Safety ................................................................................................................................... 2-1
Fuel and Propane Gas ....................................................................................................................... 2-1
LP Gas Leaks .................................................................................................................................... 2-2
Propane Gas Leak Detector .............................................................................................................. 2-2
Carbon Monoxide Warning .............................................................................................................. 2-3
Carbon Monoxide Alarm .................................................................................................................. 2-3
Smoke Alarm .................................................................................................................................... 2-4
Fire Extinguisher ............................................................................................................................... 2-4
Electrical ........................................................................................................................................... 2-5
Loading ............................................................................................................................................. 2-5
Maintenance ...................................................................................................................................... 2-5
Emergency Exits ............................................................................................................................... 2-5
Power Sofas and Beds ....................................................................................................................... 2-6
Slideout Rooms ................................................................................................................................. 2-7
Formaldehyde Information ............................................................................................................... 2-7
Mold, Moisture, and Your Motor Home ........................................................................................... 2-7
Roof and Ladders .............................................................................................................................. 2-8
Roadside Emergency ........................................................................................................................ 2-9
Jump Starting .................................................................................................................................. 2-10
Engine Overheat ............................................................................................................................. 2-10
Seats - Driver/Co-Pilot ..................................................................................................................... 3-1
Fold-Down Dinette Seat ................................................................................................................... 3-1
Seat Belts .......................................................................................................................................... 3-1
Child Restraints ................................................................................................................................. 3-2
Rev. 1112110502

TABLE OF CONTENTS

Copyright 2010 Winnebago Industries, Inc. All rights reserved.
Part No. 161500-11-002

Advertisement

Table of Contents
loading
Need help?

Need help?

Do you have a question about the Impulse and is the answer not in the manual?

Questions and answers

Summary of Contents for Winnebago Impulse

  • Page 1: Table Of Contents

    Engine Overheat ..........................2-10 3 – DRIVING YOUR MOTOR HOME Seats – Driver/Co-Pilot ........................3-1 Fold-Down Dinette Seat ........................3-1 Seat Belts ............................3-1 Child Restraints ..........................3-2 Rev. 1112110502 Part No. 161500-11-002 Copyright 2010 Winnebago Industries, Inc. All rights reserved.
  • Page 2 Table Of Contents Keys ..............................3-3 Hazard Warning Flashers ........................3-3 Mirrors – Power Sideview Exterior ....................3-3 Mirrors – Power Sideview Exterior ....................3-4 Battery Boost Switch ........................3-5 Air Conditioner/Heater – Automotive (Dash) .................. 3-5 Radio In-Dash/Rearview Monitor System ..................3-5 Radio –...
  • Page 3 Table Of Contents Ground Fault Circuit Interrupter ....................... 6-4 Electrical Generator – 120-Volt ......................6-4 Electrical System – House 12-Volt DC .................... 6-5 House/Coach Battery Disconnect Switch ..................6-6 Battery Access ..........................6-6 Battery Care ............................6-7 Circuit Breakers and Fuses – House 12-Volt DC ................6-8 7 –...
  • Page 4 Dinette Conversion ........................... 9-5 Comfort Sofa Sleeper ........................9-5 Roller Shades (Manual) - Solar Day/Night ..................9-9 Wood Furniture and Cabinetry ......................9-9 10 – SLIDEOUT ROOMS Slideout Room Travel Lock ......................10-1 Slideout Room Operation – Electric ....................10-2 Slideout Room –...
  • Page 5 Storage Compartment Doors ......................12-7 Tool and Ladder Storage ......................... 12-7 Roof Ladder ............................ 12-7 Windows ............................12-8 Power Roof Ventilator ........................12-9 Effects of Prolonged Occupancy ....................12-9...
  • Page 7: Introduction

    DANGER indicates a hazardous situation are intended as a guide, and in no way which, if not avoided, will result in death or extend the responsibilities of Winnebago serious personal injury. Industries beyond the standard written warranty as presented in this manual.
  • Page 8: Pre-Delivery Inspection

    National Highway Traffic Safety Administration (NHTSA) in addition to notifying Winnebago PRE-DELIVERY INSPECTION Industries, Inc. If NHTSA receives similar complaints, it may...
  • Page 9: Occupant And Cargo Carrying Capacity Label

    SECTION 1 – INTRODUCTION You can also obtain other information about motor vehicle safety from the NHTSA website at http://www.safercar.gov OCCUPANT AND CARGO CARRYING CAPACITY LABEL This label is affixed in the driver’s area next to or near the Vehicle Certification Label. It contains vehicle occupant and cargo carrying capacity along with the number of seat belt positions in the vehicle.
  • Page 10: Vehicle Certification Label

    These pressure levels must be maintained to assure proper handling, safety, 2. Chassis manufacture date. and fuel economy. 3. Month and year of manufacture at Winnebago ® 9. Rear Axle Wheel Configuration: Single or Industries Dual as it relates to the inflation.
  • Page 11: Specifications And Capacities

    SECTION 1 – INTRODUCTION SPECIFICATIONS AND CAPACITIES Standard Optional ® ® ® ® Itasca Impulse Ford E450 Ford E450 Ford E450 Ford E450 ® ® Ford E350 Ford E450 Chassis Chassis Chassis Chassis Chassis Chassis Feature Number Length 25' 0.1"...
  • Page 12: Owner And Vehicle Information

    Motor Home Serial Number __________________________________________________________ Chassis Vehicle Identification No. (VIN) ________________________________________________ Vehicle Mileage at Delivery __________________________________________________________ Selling Dealer Name ________________________________________________________________ Address __________________________________________________________________________ __________________________________________________________________________ ® YOUR WINNEBAGO INDUSTRIES DEALER /SERVICE CENTER Name ____________________________________________________________________________ Address __________________________________________________________________________ __________________________________________________________________________ Contact ____________________________________________Phone ________________________ CHASSIS SERVICE CENTER...
  • Page 13: 2011 New Vehicle Limited Warranty

    Chassis, drivetrain and related components* Winnebago Industries, Inc. of Forest City, Iowa, warrants each new Wheels* Winnebago and Itasca motor home to the owner for recreational use Tires* in the U.S.A. and Canada as follows: Any other part or component covered by a written warranty issued by...
  • Page 14 If you are touring or have moved, contact any unresolved warranty disputes for recreational vehicles. This dispute Winnebago Industries motor home dealer in the United States or resolution program reviews eligible product and service related Canada for warranty service.
  • Page 15: Safety And Precautions

    SECTION 2 – SAFETY AND PRECAUTIONS • Use care when accelerating or decelerating on GENERAL WARNINGS a slippery surface. Abrupt speed changes can cause skidding and loss of control. • Only seats equipped with seat belts are to be occupied while the vehicle is moving. •...
  • Page 16: Lp Gas Leaks

    SECTION 2 – SAFETY AND PRECAUTIONS • All pilot lights must be extinguished and asphyxiation is greater when the appliance is appliances turned off while refilling the fuel used for long periods of time. Failure to comply tank or LP gas tank. could result in death or serious injury.
  • Page 17: Carbon Monoxide Warning

    SECTION 2 – SAFETY AND PRECAUTIONS The best protection against carbon monoxide entry into the vehicle body is a properly maintained engine exhaust and ventilation WARNING system. It is recommended that the exhaust system and body be inspected by a qualified EXPLOSION HAZARD: DO NOT use an motor home service center: open flame to test for gas leaks.
  • Page 18: Smoke Alarm

    RV application. We Replacement recommend obtaining a replacement from your ® When replacing this alarm, we recommend Winnebago Industries dealer. replacing only with the same model, or with one Further Information that is also listed for RV application. We...
  • Page 19: Electrical

    MAINTENANCE your coach. We recommend obtaining a replacement only from your Winnebago • Do not remove the radiator cap while engine ® Industries dealer or a reliable RV parts supplier.
  • Page 20: Power Sofas And Beds

    SECTION 2 – SAFETY AND PRECAUTIONS To open, pull on the red plastic strap at the bottom of the window to remove the rubber cord that holds the window in place. Pull on the rubber cord until it is completely removed. This allows the window to be pushed out.
  • Page 21: Slideout Rooms

    SECTION 2 – SAFETY AND PRECAUTIONS contaminants to accumulate in indoor air. SLIDEOUT ROOMS Ventilation to dilute the indoor air may be obtained from a passive or mechanical ventilation system. Always be sure to thoroughly ventilate your recreational vehicle before and WARNING during each use.
  • Page 22: Roof And Ladders

    SECTION 2 – SAFETY AND PRECAUTIONS Minimize moisture in your motor home and warranty period, Winnebago Industries will not keep humidity low. Clean spills quickly. Do not provide any financial assistance to the repair of allow condensation to build up. You can open the condition.
  • Page 23: Roadside Emergency

    SECTION 2 – SAFETY AND PRECAUTIONS • Make sure you are physically capable to • Let the vehicle coast to a stop, gently steering safely use the ladder. Strength, flexibility, and to a safe stopping place off the traffic lanes of stability are required.
  • Page 24: Jump Starting

    We recommend that you ask for an underlift (wheel lift or frame lift) type towing assembly for safe towing. ® Winnebago Industries does not assume ENGINE OVERHEAT responsibility for damage incurred while towing If you see or hear steam escaping from the this vehicle.
  • Page 25: Driving Your Motor Home

    SECTION 3 – DRIVING YOUR MOTOR HOME The information in this section refers only to features installed or adapted to the dash and driver compartment area by Winnebago ® Industries . It also includes passenger seating in the living area of the coach.
  • Page 26: Child Restraints

    SECTION 3 – DRIVING YOUR MOTOR HOME Lap/Shoulder Belts protection of the safety belt, never let more than one person use the same safety belt at any one See your chassis manual for instructions on time, and do not let the safety belts become proper fastening, adjustment, and releasing of damaged by pinching them in the doors or in the lap/shoulder belts.
  • Page 27: Keys

    SECTION 3 – DRIVING YOUR MOTOR HOME Further Information 3. Be certain that it is appropriate for the child's height, weight, and development. The See the child seat manufacturer’s specific instructions and/or the regulation label instructions for proper attachment and attached to the restraint typically provides this adjustment of the tether and seat belts.
  • Page 28 SECTION 3 – DRIVING YOUR MOTOR HOME Mirror Heat Switch Mirror Adjustment Control Mirror Pivot Lock • Mirror surface tilts in direction Unscrew protective cap and of arrow button pressed. loosen Allen head set screw • Middle switch selects L or R mirror to adjust.
  • Page 29: Battery Boost Switch

    SECTION 3 – DRIVING YOUR MOTOR HOME Press and Hold the Battery Boost switch in the ON position while turning ignition key for Mirror Heat emergency starting power. Switch NOTE: The House/Coach Battery Disconnect switch near the entrance door must be ON and house batteries must be sufficiently charged for this feature to work.
  • Page 30 SECTION 3 – DRIVING YOUR MOTOR HOME Satellite Radio –If Equipped ® Your coach may be equipped with a Sirius satellite radio receiver that plays through your radio. See the receiver manufacturer’s information in your InfoCase for programming and operating instructions.
  • Page 31: Radio - In-Dash

    SECTION 3 – DRIVING YOUR MOTOR HOME RADIO – IN-DASH -If Equipped The radio in your coach can receive AM/FM stereo and weather band stations. It also has a compact disc (CD) player for your listening enjoyment through quality high-output speakers located in several areas of the coach.
  • Page 32: Engine Access - Interior

    SECTION 3 – DRIVING YOUR MOTOR HOME For complete operating instructions, see the owners manual of your headunit. When your Sirius radio is connected via the SiriusConnect Docking Kit to your headunit, the buttons and controls of the Sirius radio will be disabled, and a SiriusConnect message or logo Front Engine Cover will be displayed.
  • Page 33: Suspension Alignment And Tire Balance

    SECTION 3 – DRIVING YOUR MOTOR HOME AIR SPRINGS – REAR HELPER (AIR BAGS) WARNING –If Equipped The rear air helper springs (air bags) are an Make sure all replacement tires are of the same size and rating as those shown on enhancement to the standard suspension system your Vehicle Certification Label.
  • Page 34: Lights

    SECTION 3 – DRIVING YOUR MOTOR HOME LIGHTS All exterior lights should be checked for proper operation each time the vehicle is prepared for a trip. Any bulbs which fail to light should be checked and replaced, when necessary, with a new bulb of the same size. A failure of more than one light, such as both taillights not operating, may indicate a burned out fuse.
  • Page 35: Appliances And Systems

    SECTION 4 – APPLIANCES AND SYSTEMS The appliances installed in your motor home are manufactured by reputable RV appliance makers and have been tested by independent laboratories to meet all applicable standards and codes set for RV appliances. See Section 2 - Safety and Precautions of this manual for any safety and precautions you need to take regarding the operation of your appliances.
  • Page 36: Refrigerator Service Access Compartment

    SECTION 4 – APPLIANCES AND SYSTEMS To Open 1. Use a screwdriver or coin to turn the latch knobs to the vertical position as shown. Refrigerator Access Door Latches • Gas- Refrigerator will operate on gas from the propane tank if the main valve is open and the 2.
  • Page 37: Microwave Oven

    SECTION 4 – APPLIANCES AND SYSTEMS To Light Range Top Burners Unlike homes, the amount of oxygen supply is •Turn the desired burner knob to HI LITE position limited due to the size of the recreational vehicle, •Immediately spin the IGNITOR knob clockwise and proper ventilation when using the cooking at least one full turn to light the burner appliances avoids dangers of asphyxiation.
  • Page 38: Range Hood

    SECTION 4 – APPLIANCES AND SYSTEMS RANGE HOOD -If Equipped The range hood vent draws cooking odors and airborne grease particles into the filtration grid and either recirculates the air or vents it to the outside of the coach, depending on model. A light on the underside of the hood provides illumination for cooking and food preparation.
  • Page 39: Water Heater - Gas/ Electric

    SECTION 4 – APPLIANCES AND SYSTEMS The propane level is registered by a sending NOTE: Some models may be equipped with a unit on the tank. The gauge mounted on the side Water Pump switch in the water service of the tank will give a more accurate indication of center on the outside of the coach or actual tank level if needed.
  • Page 40 SECTION 4 – APPLIANCES AND SYSTEMS Further Information Read the operating and safety information provided in the Water Heater Operation Manual in your InfoCase. WATER HEATER - GAS/ ELECTRIC -If Equipped (with Motoraid water heating system) The gas/electric water heater has a dual power Gas Water Heater Switch feature.
  • Page 41: Pressure-Temperature Relief Valve

    SECTION 4 – APPLIANCES AND SYSTEMS Further Information Read the operating and safety information provided in the Water Heater Operation Manual in your InfoCase. PRESSURE-TEMPERATURE RELIEF VALVE On occasion, water may be seen seeping from the water heater pressure temperature relief valve.
  • Page 42: Propane Gas Furnace

    SECTION 4 – APPLIANCES AND SYSTEMS 2. Open a faucet in the motor home to relieve water pressure. 3. Pull the handle of the P-T valve straight out and allow water to flow until it stops. Thermostat/Switch Room Temperature •Move from OFF to Thermometer desired temperature •Lift handle straight out to open P-T valve...
  • Page 43: Propane Gas Furnace

    SECTION 4 – APPLIANCES AND SYSTEMS and periodic maintenance. See the Coach NOTE: If heat does not come out of the heat Maintenance Schedule for recommended ducts after a minute or so the burner is intervals. not lit. Turn thermostat off for 3-5 minutes, NOTE: If the furnace burner has any residuals check to be sure propane gas tank valve of metal protectant or lubricants used...
  • Page 44: Furnace-A/C Thermostat Operation Chart

    SECTION 4 – APPLIANCES AND SYSTEMS FURNACE-A/C THERMOSTAT OPERATION CHART The following chart shows the system functions with the “Heat/Cool” thermostat. Disregard references to heat functions when using the “Cool Only” thermostat in the rear bedroom. X = Switch Position O = Switch position does not matter or is inactive for this feature FAN MODE FAN SPEED...
  • Page 45: Air Conditioner Filter

    SECTION 4 – APPLIANCES AND SYSTEMS AIR CONDITIONER FILTER The washable foam filter should be checked monthly for dirt build-up and cleaned or replaced as needed. It is located in the ceiling mounted return A/C grille in the lounge area. 4-11...
  • Page 47: Propane Gas

    SECTION 5 – PROPANE GAS PROPANE GAS SUPPLY The propane gas system supplies fuel for the gas range/oven, water heater, furnace, and refrigerator (while in gas mode). When used and handled properly, this system is safe and economical and provides modern living conveniences wherever you travel.
  • Page 48: Safe Use Of The Propane Gas System

    SECTION 5 – PROPANE GAS phone directory yellow pages for locations of local propane gas refilling stations or bulk dealerships. DAN G E R NOTE: If you travel outside the U.S. with your motor home, you may find butane or DO NOT FILL CONTAINER TO MORE propane/butane mixtures available in THAN 80 PERCENT OF CAPACITY.
  • Page 49: Propane Gas Warnings And Precautions

    SECTION 5 – PROPANE GAS • Exercise caution at all times. Be familiar with PROPANE GAS WARNINGS the distinctive odor of propane gas. If a leak is AND PRECAUTIONS suspected, turn off the supply valve immediately. Have the propane gas system It is illegal for vehicles equipped with propane checked by your dealer or other qualified tanks to travel on certain roadways or through...
  • Page 50: Propane Gas Pressure Regulator

    SECTION 5 – PROPANE GAS WARNING WARNING Propane cylinders shall not be placed or Visually inspect the pressure regulator stored inside the vehicle. Propane vent periodically for blockage by cylinders are equipped with safety accumulated debris or insect nests, etc. devices that relieve pressure by Vent obstruction could result in excessive discharging propane to the atmosphere.
  • Page 51: Propane Vaporization In Cold Weather

    SECTION 5 – PROPANE GAS This means that in extremely cold weather when a large volume of gas is being used by the furnace for heating, it is possible to experience a loss of gas pressure. At first, this problem may appear to be caused by an empty tank or a regulator freeze-up, but is actually caused by failure of the liquid gas to vaporize as fast as it is needed by the furnace.
  • Page 53: Electrical

    SECTION 6 – ELECTRICAL Your coach is equipped with an electrical the power converter automatically changes a system consisting of two separate voltages: portion of the 120-volt current to 12-volt DC current. All equipment in the motor home that is •...
  • Page 54: Power Center

    SECTION 6 – ELECTRICAL The three-prong power cord is designed to ground the electrical system through the receptacle. It is also designed to carry the amperage output of most campground outlets. 30 Amp Receptacle • Route power cord through passage and close door while shoreline is If the electrical receptacle to be used is connected to outlet.
  • Page 55: Charging Section

    SECTION 6 – ELECTRICAL condition of the battery. If it is below “full 12-Volt 120-Volt charge”, the Charging Section will start charging House Fuses Circuit Breakers the batteries. If the house batteries have been extremely discharged, they will accept charge at a relatively high amperage rate.
  • Page 56: Electrical Outlets - House 120-Volt Ac

    SECTION 6 – ELECTRICAL “Off” and back to “On”. If the breaker is If the GFCI keeps tripping, have the electrical continually tripped and no overload is evident, system checked and repaired, if necessary, before have the system checked for a short in the wiring using again.
  • Page 57: Operation Warnings And Cautions

    SECTION 6 – ELECTRICAL To use the 120-volt generator, plug the power Refer to the hourmeter to determine when cord into the generator receptacle within the periodic maintenance is due and to record utility compartment before starting the generator. services which have been performed. Operation Warnings and Cautions WARNING The exhaust of all internal combustion...
  • Page 58: House/Coach Battery Disconnect Switch

    SECTION 6 – ELECTRICAL Converter Always leave this switch ON while using the coach. See “Power Center.” NOTE: Some electronic displays and memory Chassis Battery functions may need to be reset after The chassis battery is used to operate the power has been reconnected.
  • Page 59: Battery Care

    SECTION 6 – ELECTRICAL The two best defenses against sulfating and insufficient charge are to: 1. Turn off the House/Coach Battery Disconnect switch to avoid parasitic discharge (the trickle House Batteries discharge caused by directly connected components like propane gas detectors or digital clock displays, etc.) 2.
  • Page 60: Circuit Breakers And Fuses - House 12-Volt Dc

    If your coach is going to be unoccupied for metal parts. Should the cable be ® two weeks or more, Winnebago Industries damaged, a short circuit could result in recommends disconnecting the chassis battery in personal injury or damage to equipment.
  • Page 61: Volt Fuse Panel

    SECTION 6 – ELECTRICAL Circuit Breaker Panel Battery Charge Meter See related item under “Systems Monitor Panel” in Section 4 - Appliances. Battery Boost Switch See Section 3 - Driving Your Motor Home for information on the Battery Boost switch. Chassis and House 12V Breakers (Located in passenger side compartment) -Typical View...
  • Page 63: Plumbing

    SECTION 7 – PLUMBING 2. Attach an RV city water hose from the FRESH WATER SYSTEM external water source to the city water connection typically located in the water The fresh water system provides water to the service compartment or on the left sidewall of galley sink, shower, bathroom lavatory, toilet and your vehicle.
  • Page 64: Water Pump

    SECTION 7 – PLUMBING To Clean Pump Strainer Water pressure regulators are commonly available at most RV dealerships and many large • Be sure all water pump switches are OFF. retail discount or home supply centers. • Twist the inlet cap (bowl) counter-clockwise to unscrew from the strainer assembly.
  • Page 65: Disinfecting Your Fresh Water System

    SECTION 7 – PLUMBING 8. Pump is now ready for automatic operation. bleach with 1 gallon of water to prepare the Pump will start when a faucet is opened and chlorine solution. One gallon of this solution stop when the faucet is closed. should be used for each 15 gallons of tank capacity.
  • Page 66: Shower Hose Vacuum Breaker

    SECTION 7 – PLUMBING • Add 1 teaspoon of household chlorine bleach (sodium hypochlorite) to your tank for each 10 gallons of tank capacity. When you fill the tank, this will result in a 6.7 ppm level of chlorine, which should kill harmful bacteria and slime-forming organisms.
  • Page 67: Drainage System (P-Traps)

    SECTION 7 – PLUMBING Further Information Dumping Holding Tanks See the toilet manufacturer’s operation information in your InfoCase for complete operating, care and maintenance information. See winterizing instructions at the end of this section to prepare the toilet for storage in freezing conditions.
  • Page 68: Waste Water System - Waste Pump

    SECTION 7 – PLUMBING 7. Rinse sewage drain hose thoroughly with Sewage Drain water and stow. Outlet/Dust Cap NOTE: We recommend that you dump all holding tanks before traveling to avoid carrying unnecessary weight. Using On-Site Sewer Hook-Ups The sewage drain hose may remain attached to the dump outlet and be routed out the bottom of the compartment while the motor home is parked and connected to an on-site sewage hook-up.
  • Page 69: Dumping Holding Tanks

    SECTION 7 – PLUMBING Dumping Holding Tanks The black water holding tank contains the sewage from the toilet and may include the 1. Remove sewage drain hose from rear bumper bathroom lavatory on some models. The gray storage. water holding tank contains the waste water from 2.
  • Page 70 SECTION 7 – PLUMBING NOTE: DO NOT OPEN BOTH VALVES AT ONCE. Do not open the Gray Waste Tank Drain valve until the black tank is drained and dump valve closed to avoid sewage back-up into gray tank. Gray water also rinses any black water solids from the sewage drain hose.
  • Page 71: Holding Tank Heater

    SECTION 7 – PLUMBING Holding Tank Level Indicators batteries would not support overnight heating without a supplemental charging See “Systems Monitor Panel” in Section 4– source. Appliances for further information on the monitor panel and checking tank levels. WATERLINE & TANK DRAIN See “Specifications”...
  • Page 72: Water Heater Bypass Valve

    SECTION 7 – PLUMBING Normal By-Pass Flow Mode Leave bypass valve handle in NORMAL FLOW position if draining water and blowing Water Tank Drain Valve (Typical) out waterlines. Place in BYPASS position ONLY when using antifreeze solution in waterlines. WINTERIZING PROCEDURE You can winterize the water and plumbing system of your coach using one of the following two methods –...
  • Page 73 Leave open after water stops flowing. the system. A “blow-out” plug can be 5. Drain Toilet. Press the toilet flush pedal and ® ® purchased at any Winnebago or Itasca hold until water stops flowing in the toilet. dealer. Then turn water pump switch off.
  • Page 74 SECTION 7 – PLUMBING 9. Drain Toilet. Operate and hold toilet flush lever until water is completely drained from See instructions for removal from storage in toilet. Section 11 - Maintenance and Storage. 10. Turn air pressure off. Disconnect water purge adapters.
  • Page 75 SECTION 7 – PLUMBING Set Up Winterization Valves 7. Press the toilet flush pedal and hold until antifreeze begins flowing into the toilet. 1. Turn water heater bypass valve to BYPASS Leave small amount of antifreeze that remains position. (See “Water System Drain Valve in the bowl.
  • Page 76 SECTION 7 – PLUMBING Pressure-Temperature Relief Valve (Lift handle only when water heater is cold) • Reinstall the water heater drain plug and close the P-T Relief Valve when drained. Close All Drain Valves Waste Pump Drain 12. Close all waterline drains and tank drain (Located on driver side of coach valves to avoid contamination by dirt, insects, ahead of rear wheel)
  • Page 77: Water System Drain Valve Locations

    SECTION 7 – PLUMBING WATER SYSTEM DRAIN VALVE LOCATIONS MODEL SYSTEM DRAIN VALVE LOCATIONS Waterlines Three (3) valves beneath the bed. Access through removable panel on end of bed cabinet. Water Tank One (1) valve beneath the bed. Access through removable panel on end of bed cabinet.
  • Page 78 SECTION 7 – PLUMBING Waterlines • Two (2) valves beneath shower. Access through removable panel on lower front of shower cabinet. • Two (2) valves beneath the bed mattress. Lift mattress to access. Water Tank One (1) valve beneath the bed mattress. Lift mattress to expose access hole.
  • Page 79: Entertainment

    SECTION 8 – ENTERTAINMENT VIDEO SELECTION SYSTEM –If Equipped The video selection system allows you to • The Video Selection System allows you to switch the antenna, AUX/VCR, cable TV, watch DVD’s from either the lounge area satellite TV, or DVD signal to any TV set (main TV), bedroom, or the exterior location in the coach.
  • Page 80: Front Tv Ignition Switch Interlock

    SECTION 8 – ENTERTAINMENT FRONT TV IGNITION SWITCH INTERLOCK –If Equipped If your coach is equipped with a front overhead TV, it is plugged into a special electrical outlet with a built-in ignition switch interlock. The device allows the front overhead TV to operate only when the ignition key is in the Off or Accessory positions.
  • Page 81: Dvd Player

    SECTION 8 – ENTERTAINMENT • Press INPUT/SOURCE NOTE: Turn the volume level up significantly on button on front of TV or the DVD player when using the home remote and select theater as an amp for the TV through the “VIDEO 1”...
  • Page 82: Flip-Down Screen Video Players

    SECTION 8 – ENTERTAINMENT • The TV screen will display FLIP-DOWN SCREEN VIDEO the DVD player logo when PLAYERS the correct input is selected. (Rear Bunk models only) Play DVD –If Equipped • Insert DVD into player. DVD will begin to The flip-down LCD screen DVD Video load automatically.
  • Page 83: Electrical Inverter

    SECTION 8 – ENTERTAINMENT 12-Volt Master Power • Insert the CD label side down (facing you) into the slot on the side of the player. The • The Video Players operate on player will automatically switch to proper 12-volt DC current. Turn on the mode to play audio or video CD.
  • Page 84: Tv Antenna

    SECTION 8 – ENTERTAINMENT Raising Antenna to Operating Position Turn elevating crank clockwise in “UP” direction until some resistance to turning is noted (approximately 13 turns). Antenna is now in operating position. Turn amplifier power switch “ON” to receive TV signal.
  • Page 85: Tv Signal Amplifier

    SECTION 8 – ENTERTAINMENT CABLE TV HOOK-UP CAUTION A cable television connector is provided and is located in the utility compartment. To avoid equipment damage, always align directional handle to DOWN position before lowering. Never partially raise or lower antenna. Antenna must be raised fully up into operating position or lowered fully down into travel position.
  • Page 86: Tv Digital Satellite System Wiring

    ® See your authorized Winnebago Industries dealer for proper installation and sealing of roof mounted components. Interior Connection for Satellite Dishes...
  • Page 87: Furniture And Softgoods

    SECTION 9 – FURNITURE AND SOFTGOODS SLEEPING FACILITIES WARNING Do not exceed 225 lbs. maximum weight capacity. Misuse of ladder could result in death or serious injury. See Operators Manual before using ladder. WARNING • Maximum Capacity: 225 lbs. Sleeping facilities are not intended for use while vehicle is in motion.
  • Page 88: Sofa/Bed Conversion

    SECTION 9 – FURNITURE AND SOFTGOODS •Lower ladder to floor. •Make sure top of ladder ladder is properly engaged onto retainer brackets and ladder is resting firmly on floor before using. Security Latch (Located on front of sofa) - Pull OUT to release •...
  • Page 89: Dinette/Bed Conversion

    SECTION 9 – FURNITURE AND SOFTGOODS DINETTE/BED CONVERSION –If Equipped (Typical view – your coach may differ) Dinette to Bed Security Latch Handle accessible through front sofa opening 1. Release the catch on the table leg brace and fold the leg up against the bottom of the table. Security Latch Handle (Shown with sofa seat lifted) - Press DOWN to release...
  • Page 90: Dinette/Bed Conversion

    SECTION 9 – FURNITURE AND SOFTGOODS 3. Arrange dinette cushions to cover bed area. DINETTE/BED CONVERSION (Dream Dinette Table ™ Mechanism) –If Equipped (Typical view – your coach may differ) Dinette to Bed 1. Release the lock rod (located on the bottom of the table) by turning the lock rod clockwise.
  • Page 91: Dinette Conversion

    SECTION 9 – FURNITURE AND SOFTGOODS 4. Arrange dinette cushions to cover bed area. 3. Place dinette table(s) securely onto the dinette pedestal leg(s). 5. Reverse steps to convert back into dinette. DINETTE CONVERSION –If Equipped (Typical view – your coach may be featured -Typical View with two dinette tables and pedestal legs, depending on model)
  • Page 92 SECTION 9 – FURNITURE AND SOFTGOODS Sofa to Bed 3. Rotate the lever lock (located on the bottom right-hand side of the sofa air bed) 1. Remove seat back cushions and set aside. “clockwise” to release the bottom section of the sofa air bed.
  • Page 93 SECTION 9 – FURNITURE AND SOFTGOODS 7. Press and Hold the ADJUST button on the hand control to adjust the firmness of your air mattress to the setting that best suits your NOTE: The air mattress is plugged into an AC needs.
  • Page 94 SECTION 9 – FURNITURE AND SOFTGOODS NOTE: If using Deflation Valve to deflate air 3. Lift up the bottom section of the sofa bed and mattress, pressing down on the mattress bring all the way up. itself and forcing air out will speed up the deflation process.
  • Page 95: Roller Shades (Manual) - Solar Day/Night

    SOLAR DAY/NIGHT People are drawn to the natural beauty of ® –If Equipped wood. At Winnebago Industries , our craftsmen work with the art found in each piece of wood to Your coach may feature two-stage day/night create cabinets of superior quality, backed by the roller shades that provide both solar heat Winnebago Industries warranty.
  • Page 96 No matter which species you choose for your new Winnebago Industries motorhome cabinetry, please keep in mind that no two pieces of wood are exactly the same.
  • Page 97: Slideout Rooms

    SECTION 10 – SLIDEOUT ROOMS To Secure Lock Rod SLIDEOUT ROOM TRAVEL • Place the flat plate end of the lock rod against LOCK the outer wall of the coach about 6” down –If Equipped from the top edge of the forward end of the retracted slideout room (behind the driver seat Some models are equipped with an in most cases).
  • Page 98: Slideout Room Operation - Electric

    SECTION 10 – SLIDEOUT ROOMS NOTE: We recommend that you KEEP THE SLIDEOUT ROOM OPERATION ENGINE RUNNING WHILE – ELECTRIC EXTENDING OR RETRACTING SLIDEOUT ROOMS so the engine alternator can provide maximum power for proper operation of the slideout WARNING mechanisms.
  • Page 99: Slideout Room - Extreme Weather Precaution

    SECTION 10 – SLIDEOUT ROOMS Extend Procedure: If it has rained recently before you retract the slideout room, we recommend using the See “Before Extending!” before proceeding. hydraulic leveling system (if equipped) to lean • Start the engine so the alternator can provide the coach and drain off any excess water possibly maximum power for proper operation of remaining on the roof before retracting.
  • Page 100: Slideout Room Troubleshooting - Electric

    SECTION 10 – SLIDEOUT ROOMS slideout room cover-awning (if equipped) or • The circuit breaker may be tripped. The reduce effectiveness of the slideout room weather circuit breaker, labeled “Slideout Power” is seals. located on a panel on an interior wall of the passenger side storage compartment just behind or ahead of the entrance door.
  • Page 101 SECTION 10 – SLIDEOUT ROOMS • Take your RV to an authorized service center In the event of a total system failure where for repair. Manual Mode cannot be used, two crank handles may be used to retract or extend the room. See Before operating the room after an error has Slideout Emergency Retraction - Electric been detected, check for obvious faults such as...
  • Page 102: Slideout Emergency Retraction

    SECTION 10 – SLIDEOUT ROOMS • Take your RV to an authorized service center 1) Lift tab inside for repair. protrusion on boot to Further Information disengage motor brake See the slideout room operating guide included in your InfoCase for further instructions and troubleshooting information.
  • Page 103: Slideout Emergency Retraction - Bedroom

    SECTION 10 – SLIDEOUT ROOMS Further Information 1) Lift tab inside See the slideout manufacturer’s user guide protrusion on boot to provided in your InfoCase for further instructions disengage motor brake and troubleshooting information. SLIDEOUT EMERGENCY RETRACTION - BEDROOM -If Equipped If the slideout mechanism is malfunctioning and the room will not retract using the interior control switch, you may need to access the...
  • Page 104: General Slideout Care

    SECTION 10 – SLIDEOUT ROOMS GENERAL SLIDEOUT CARE • Wipe outer seals occasionally with talc or 303 brand protectant for smooth quiet operation. • Clean the floors inside before retracting the room to avoid floor scratches or carpet pile snags. •...
  • Page 105: Maintenance And Storage

    • Have the sealant replaced if you notice any of attention. Delaying these repairs may allow water the above. Your local Winnebago Industries leakage and result in damage to interior ceiling dealer has the correct and necessary parts and and body panels, upholstery, etc., which is not experience to help you maintain your sealants.
  • Page 106: Exterior Finish

    SECTION 11 – MAINTENANCE AND STORAGE weight to the vehicle. This, in effect, reduces the • Wash with cool water out of direct sunlight amount of cargo you can carry and remain within using a mild liquid soap (any “no-tears” baby GVWR and GAWR limits.
  • Page 107: Care Of Appliques And Decals

    SECTION 11 – MAINTENANCE AND STORAGE If the finish begins to look dull or discolored, CARE OF APPLIQUES AND it may need to be cleaned with a polishing or DECALS cleaning compound formulated for gel-coated fiberglass finishes. The pressure-sensitive appliques and decals on your coach require very little maintenance.
  • Page 108: Exterior Lights

    SECTION 11 – MAINTENANCE AND STORAGE EXTERIOR LIGHTS ® Most Winnebago Industries vehicles have NOTICE polycarbonate lenses on exterior lamps, which are very sensitive to a variety of chemical Do not use citrus-based cleaners on solvents and cleaners. polycarbonate finishes. Citric compounds...
  • Page 109: Ceiling Fabric Care

    SECTION 11 – MAINTENANCE AND STORAGE shades should be closed when the motor home is parked for an extended period of UltraLeather Cleaning Chart time. Detergent/ Cleaner/ Type of Stain Water Degreaser Coffee, Tea WARNING Red Wine, Liquor Cola, Soft Drinks Milk When cleaning upholstery and fabric, do not use lacquer thinner, nail polish...
  • Page 110: Water Stains

    SECTION 11 – MAINTENANCE AND STORAGE These materials are made from polypropylene Most commercially available carpet and or polyester synthetic fibers, so they clean very upholstery cleaners will do an excellent job well with virtually no damage to the color or removing stains.
  • Page 111: Cabinetry - Cleaning

    SECTION 11 – MAINTENANCE AND STORAGE stubborn stains, perform the following CABINETRY – CLEANING procedures for your stainless steel appliances to start shining again. Wooden items may be cleaned with a soft cloth and a good quality wood finish cleaning Scale product.
  • Page 112: Galley Sink

    SECTION 11 – MAINTENANCE AND STORAGE • Do not use abrasive powder detergents that NOTE: Do not use steel wool or metal scouring could ruin the surface finish. pads. • Do not use wool, abrasive brushes, or tools Mineral Based Stains. that have previously cleaned other metals, Cleaners designed to remove iron or rust because as well as scratching the surface, they...
  • Page 113: Doors And Windows

    SECTION 11 – MAINTENANCE AND STORAGE Tub and Shower Walls 5. Fully charge the batteries. Batteries must have at least 80% charge to survive The tub and shower walls in the bathroom freezing temperatures and long period of should be cleaned with mild soap and warm non-use.
  • Page 114: Vehicle Storage - Removal

    SECTION 11 – MAINTENANCE AND STORAGE 12. Clean the interior of the coach. Dirt and stains 12. Check around all appliances for obstructions are more easily removed when fresh. and ensure that all vent openings are clear. 13. Start refrigerator and check for proper cooling.
  • Page 115: Coach Maintenance Chart

    SECTION 11 – MAINTENANCE AND STORAGE COACH MAINTENANCE CHART These recommendations apply for normal recreational use. Heavy duty or full-time use may require more frequent maintenance intervals. Always use specified sections or manufacturer’s guide for further information and instructions. Propane Gas System Have propane gas system checked for leaks Pressure Regulator - inspect and adjust if needed Check propane tank condition, mounting, and fittings...
  • Page 116 SECTION 11 – MAINTENANCE AND STORAGE COACH MAINTENANCE CHART These recommendations apply for normal recreational use. Heavy duty or full-time use may require more frequent maintenance intervals. Always use specified sections or manufacturer’s guide for further information and instructions. Safety Equipment Check operation of the following items: Headlights, Taillights, and Marker Lights Turn Signals...
  • Page 117 SECTION 11 – MAINTENANCE AND STORAGE COACH MAINTENANCE CHART These recommendations apply for normal recreational use. Heavy duty or full-time use may require more frequent maintenance intervals. Always use specified sections or manufacturer’s guide for further information and instructions. Sealants Inspect (see “Sealants”...
  • Page 119: Miscellaneous

    SECTION 12 – MISCELLANEOUS NOTE: We recommend that you dump all LOADING THE VEHICLE holding tanks before traveling to avoid carrying unnecessary weight. NOTE: Your motor home’s load capacity is designated by weight, not by volume, so you cannot necessarily use all available space when loading your motor home.
  • Page 120 SECTION 12 – MISCELLANEOUS Corner Weighing (Side-to-Side) You will first drive only your front wheels onto the scale pad, then drive ahead so that the The most accurate method of weighing a whole vehicle is on the scale, then finally pull off motor home is to weigh each “corner”...
  • Page 121: Car Or Trailer Towing

    SECTION 12 – MISCELLANEOUS axle is 12,000 lbs., then the load on each rear dual listed Gross Weight Ratings. See “Vehicle set (left rear duals or right rear duals) should not Certification Label” in the Introduction section exceed 6,000 lbs. for information on gross weight ratings.
  • Page 122: Trailer Wiring Connector

    SECTION 12 – MISCELLANEOUS Before descending a steep or long grade when TRAILER WIRING towing a trailer, reduce speed and shift into a CONNECTOR lower gear to control vehicle speed. Avoid prolonged or frequent application of brakes, Your coach is pre-wired for trailer or car which could cause overheating and brake failure.
  • Page 123: Entry Step - Manual

    350 vehicle drive train: engine and cooling systems, lbs. All Winnebago Industries models transmission, drive line, drive axle, and others. equipped with a Class IV hitch have a...
  • Page 124: Entry Step - Electric

    SECTION 12 – MISCELLANEOUS ENTRY STEP – ELECTRIC –If Equipped WARNING Do not use step unless fully extended. Do NOT stand on step when vehicle ignition switch is turned to either the “On” or “Start” position. The step will automatically retract, which may cause personal injury.
  • Page 125: Power Awning

    SECTION 12 – MISCELLANEOUS To ensure that exterior storage compartment POWER AWNING doors have latched properly, press firmly on the bottom edges of the doors with the palms of your –If Equipped hands while twisting latches. The awning control switch is located near the entrance door.
  • Page 126: Windows

    SECTION 12 – MISCELLANEOUS • Never ignore warning labels or weight limits defined on your ladder. The following warning label is located on or near the ladder: WARNING Do not exceed 225-lb. maximum weight capacity. Misuse of ladder could result in death or serious injury. See Operators Manual before using ladder.
  • Page 127: Power Roof Ventilator

    SECTION 12 – MISCELLANEOUS 2. The turbine fan will start automatically as the vent dome is raised and stop as the vent dome is lowered and closed. (Fan Speed knob must be in a position other than 0-Off). 3. Turn the Fan Speed knob to the desired level (1-Low, 2-Med, 3-Hi).
  • Page 128 SECTION 12 – MISCELLANEOUS You can help reduce excessive moisture inside the motor home by taking the following steps: Ventilate with outside air Partially open one or more windows and a roof vent to circulate outside air through the coach. In cold weather, this ventilation may increase use of the furnace, but it will greatly reduce the condensation inside the coach.
  • Page 129 INDEX 2011 New Vehicle Limited Warranty ..1-7 Emergency Exits .......... 2-5 About this Manual ........1-1 Engine Access – Interior ......3-8 Air Conditioner Filter ........ 4-11 Engine Cooling System ....... 3-8 Air Conditioner/Heater – Engine Overheat ........2-10 Automotive (Dash) ........
  • Page 130 Index Owner and Vehicle Information ....1-6 Slideout Rooms ..........2-7 Plastic Parts – Cleaning ......11-3 Smoke Alarm ..........2-4 Power Awning ........... 12-7 Sofa/Bed Conversion ........9-2 Power Center ..........6-2 Sofa/Bed Conversion ........9-2 Power Roof Ventilator ....... 12-9 specifications and Capacities .......

Table of Contents