Table of Contents

Advertisement

Quick Links

Rev. 2006200228
Part No. 161500-20-019
Copyright 2020 Winnebago Industries, Inc. All rights reserved.

Advertisement

Table of Contents
loading
Need help?

Need help?

Do you have a question about the INTENT and is the answer not in the manual?

Questions and answers

mike allkee
May 14, 2025

`cabin filter is behind the glove box there is not one 2018 intent r30

Summary of Contents for Winnebago INTENT

  • Page 1 Rev. 2006200228 Part No. 161500-20-019 Copyright 2020 Winnebago Industries, Inc. All rights reserved.
  • Page 3: Table Of Contents

    TABLE OF CONTENTS 1 - INTRODUCTION About this Manual ..........................1-1 Safety Messages Used in this Manual ....................1-1 Pre-Delivery Inspection ........................1-2 Before Driving ..........................1-2 Front Axle Tire Alignment ....................... 1-2 Headlight Alignment ......................... 1-2 Service and Assistance ........................1-2 Reporting Safety Defects ........................
  • Page 4 Table Of Contents Mirrors – Power Electric ........................3-4 Brake-Shift Interlock ........................3-5 Park Brake – Foot Pedal ........................3-5 Tow/Haul Transmission Mode ......................3-6 Front Drop-Down Shade (12-Volt) ....................3-6 Hazard Warning Flashers ........................3-7 Traction Control Button ........................3-7 Battery Boost Switch ........................
  • Page 5 Table Of Contents Electrical Outlets – House 120-Volt AC ..................6-5 Electrical Generator – 120-Volt ......................6-5 Electrical System – House 12-Volt DC .................... 6-6 House/Coach Battery Disconnect Switch ..................6-7 Battery Access ..........................6-7 Battery Care ............................6-7 Circuit Breakers and Fuses – House 12-Volt DC ................6-9 7 - PLUMBING Fresh Water System ..........................
  • Page 6 Table Of Contents Leveling System ..........................10-4 Checking Hydraulic Oil Level ......................10-5 11 - MAINTENANCE AND STORAGE Sealants – Inspection and General Information ................11-1 Roof ..............................11-1 Undercarriage ..........................11-1 Exterior Finish ..........................11-2 Exterior Graphic Care ........................11-3 Plastic Parts –...
  • Page 7: Introduction

    The instructions included in this manual are intended as a guide, and in no way DANGER indicates a hazardous situation extend the responsibilities of Winnebago which, if not avoided, will result in death or Industries beyond the standard written serious personal injury.
  • Page 8: Pre-Delivery Inspection

    BEFORE DRIVING National Highway Traffic Safety Administration Familiarize yourself with State/Province and (NHTSA) in addition to notifying Winnebago local regulations before traveling. There are Industries, Inc. many local rules that may impact your travels.
  • Page 9: Occupant And Cargo Carrying Capacity Label

    However, NHTSA cannot become involved in individual problems between you, your dealer, or Winnebago Industries, Inc. To contact NHTSA, you may either call the Vehicle Safety Hotline toll-free at: 1-888-327-4236; (TTY: 1-800-424-9153) or go to http://www.safercar.gov...
  • Page 10: Vehicle Certification Label

    These pressure levels must be maintained to assure proper handling, safety, 2. Chassis manufacture date. and fuel economy. 3. Month and year of manufacture at Winnebago 9. Rear Axle Wheel Configuration: Single or ® Industries Dual as it relates to the inflation.
  • Page 11: Specifications And Capacities

    80 gal. Notes: All information is based upon the most recent data available. Visit the Winnebago Industries, Inc. web page – www.winnebagoind.com – for the most current product information. The height of each model is measured to the top of the tallest standard feature and is based on the curb weight of a typically equipped unit.
  • Page 12: Owner And Vehicle Information

    Motorhome Serial Number ___________________________________________________________ Chassis Vehicle Identification No. (VIN) ________________________________________________ Vehicle Mileage at Delivery __________________________________________________________ Selling Dealer Name ________________________________________________________________ Address __________________________________________________________________________ __________________________________________________________________________ ® YOUR WINNEBAGO INDUSTRIES DEALER /SERVICE CENTER Name ____________________________________________________________________________ Address __________________________________________________________________________ __________________________________________________________________________ Contact ____________________________________________Phone ________________________ CHASSIS SERVICE CENTER...
  • Page 13: Safety And Precautions

    SECTION 2 - SAFETY AND PRECAUTIONS GENERAL WARNINGS WARNING • Only seats equipped with seat belts are to be occupied while the vehicle is moving. • Make sure all passengers have seat belts Operating, servicing and maintaining this vehicle can expose you to chemicals fastened.
  • Page 14: Driving Safety

    SECTION 2 - SAFETY AND PRECAUTIONS • Do not operate the cruise control on icy or DRIVING SAFETY extremely wet roads, winding roads, in heavy traffic, or in any other traffic situation where a constant speed cannot be maintained. WARNING •...
  • Page 15 SECTION 2 - SAFETY AND PRECAUTIONS • Portable fuel-burning equipment, including wood and charcoal grills and stoves shall not WARNING be used inside the recreational vehicle. The use of this equipment inside the recreational vehicle may cause fires or asphyxiation. Do not fill propane container(s) to more •...
  • Page 16: Propane Gas Leaks

    Replacement When replacing this alarm, we recommend replacing only with the same model, or with one that is also listed for RV application. We recommend obtaining a replacement from your ® Winnebago Industries dealer.
  • Page 17: Carbon Monoxide Warning

    RV application. We Do not run engine in confined areas, such as a recommend obtaining a replacement from your garage, except to move vehicle into or out of the ® Winnebago Industries dealer. area. Further Information CARBON MONOXIDE ALARM...
  • Page 18: Smoke Alarm

    When replacing this alarm, we recommend your motorhome. We recommend obtaining a replacing only with the same model, or with one replacement only from your Winnebago ® that is also listed for RV application. We Industries dealer or a reliable RV parts supplier.
  • Page 19: Loading

    SECTION 2 - SAFETY AND PRECAUTIONS • Improper grounding of the vehicle can cause • Do not mix different construction types of personal injury. Do not plug the utility power tires on the vehicle, such as radial, bias, or cord into an outlet which is not grounded and belted tires, as vehicle handling may be do not adapt the plug to connect to a receptacle affected.
  • Page 20: Slideout Rooms

    SECTION 2 - SAFETY AND PRECAUTIONS WARNING Keep all persons clear of the slideout room and moving parts while extending or retracting. Do not occupy the slideout room while it is being extended or retracted. Failure to observe can result in death or serious injury.
  • Page 21: Formaldehyde Information

    SECTION 2 - SAFETY AND PRECAUTIONS during each use. High indoor temperatures and humidity may raise formaldehyde levels. When a WARNING recreational vehicle is in areas subject to high temperatures, an air conditioning system can be used to control indoor temperature levels. If you Do not exceed 225-lb.
  • Page 22: Roadside Emergency

    If you must change lanes to get to a safe replace affected items as it deems necessary. This stopping place, use your signals to warn other is the extent of coverage provided by Winnebago motorists and change lanes smoothly and Industries. Winnebago Industries, however, will carefully after you are certain the lane is clear.
  • Page 23: Jump Starting

    Label. This will allow the towing operator to is safe to do so, stop the engine, and get all determine the proper towing equipment to use. passengers out of the vehicle. ® Winnebago Industries does not assume responsibility for damage incurred while towing this vehicle. NOTICE...
  • Page 25: Driving Your Motorhome

    The information in this section refers only to • Lift to features installed or adapted to the dash and Recline driver compartment area by Winnebago ® Industries . It also includes passenger seating in the living area of the motorhome.
  • Page 26: Seat Belts

    SECTION 3 - DRIVING YOUR MOTORHOME SEAT BELTS WARNING Seats intended for occupancy while the vehicle is in motion are equipped with seat belts for the protection of the driver and passengers. Snug and low belt positions are essential. This will ensure that the force exerted by Lap Belts the lap belt in a collision is spread over the The lap belts must be worn as low as possible...
  • Page 27: Child Restraints

    SECTION 3 - DRIVING YOUR MOTORHOME Tether Anchor Loop • Inspect the belts and hardware periodically. Check for cuts, frays, and loose parts. –If Equipped Damaged parts should be replaced. Do not If your motorhome has a dinette, it may be remove or modify the belt system.
  • Page 28: Keys

    SECTION 3 - DRIVING YOUR MOTORHOME KEYS Your motorhome is supplied with several keys. In addition to the chassis manufacturer’s ignition key, you receive keys for the entrance door and exterior compartment doors. Keys have an identification number, either a small metal tag or stamped into the key head.
  • Page 29: Brake-Shift Interlock

    SECTION 3 - DRIVING YOUR MOTORHOME BRAKE-SHIFT INTERLOCK ® Ford Chassis The Brake-Shift Interlock is a safety feature that prevents the shift lever from being moved from the Park position unless the ignition is ON and the service brake pedal is pressed. NOTE: If the brake light fuse is blown, the interlock feature will not work properly and an alternate method must be used.
  • Page 30: Tow/Haul Transmission Mode

    The power switch for the 12V Front Drop- Should the Automatic Safety Retraction Down Night Shade is located on the driver trim feature deploy, go to your nearest Winnebago ® panels. Industries dealer for service before operating the shade again.
  • Page 31: Hazard Warning Flashers

    SECTION 3 - DRIVING YOUR MOTORHOME Further Information BATTERY BOOST SWITCH Refer to the manufacturer’s user guide The Battery Boost switch can be used to draw provided in your InfoCase for complete operating emergency starting power from the house instructions, troubleshooting tips, and batteries to start the engine if the chassis battery maintenance care.
  • Page 32: Radio In-Dash/Rearview Monitor System

    SECTION 3 - DRIVING YOUR MOTORHOME Basic Operating Instructions NOTE: The dash air conditioner/heater is not designed to heat and cool the entire • (1) Volume (+/-). interior of the motorhome, but is • (2) Mute intended only to provide heating and •...
  • Page 33: Front Service Access

    SECTION 3 - DRIVING YOUR MOTORHOME Further Information See the manufacturer’s user guide provided in your InfoCase for complete operating instructions. • Bluetooth Microphone FRONT SERVICE ACCESS (HOOD) The Hood Panel can be opened for access to service items such as the engine oil dipstick, oil •...
  • Page 34: Engine Access - Interior

    SECTION 3 - DRIVING YOUR MOTORHOME To Reinstall the Engine Cover • Press top edge of hood panel in with palms of hands, while locking Hood Locks with the • Position the front end of the cover first, then provided Hood Lock Key (located on key lower the rear end.
  • Page 35: Suspension Alignment And Tire Balance

    SECTION 3 - DRIVING YOUR MOTORHOME should be checked and replaced, when necessary, with a new bulb of the same size. A failure of WARNING more than one light, such as both taillights not operating, may indicate a burned out fuse. Check fuse and replace with one of the same rating Make sure all replacement tires are of the when necessary.
  • Page 37: Appliances And Systems

    SECTION 4 - APPLIANCES AND SYSTEMS The appliances installed in your motorhome are manufactured by reputable RV appliance makers and have been tested by independent WARNING laboratories to meet all applicable standards and codes set for RV appliances. At refrigerator/freezer or motorhome End See Section 2 - Safety and Precautions of this of Life remove travel latch.
  • Page 38: Range And Oven

    SECTION 4 - APPLIANCES AND SYSTEMS –If Equipped NOTE: See the appliance manufacturer’s user guide provided in your InfoCase for complete operating instructions and safety precautions. The Range and optional Oven in your motor home operate on propane gas and will provide most of the functions of the range in your home.
  • Page 39: Microwave Oven

    SECTION 4 - APPLIANCES AND SYSTEMS NOTICE WARNING Do not store items in oven. Gas cooking appliances need fresh air for If oven would turn on stored items can safe operation. ignite resulting in fire and or property Before operating: damage.
  • Page 40: Range Hood

    SECTION 4 - APPLIANCES AND SYSTEMS NOTICE Do not store items in oven. If oven would turn on stored items can ignite resulting in fire and or property damage. RANGE HOOD –If Equipped The range hood vent draws cooking odors and airborne grease particles into the filtration grid and either recirculates the air or vents it to the outside of the motorhome, depending on model.
  • Page 41: Water Heater - Gas

    SECTION 4 - APPLIANCES AND SYSTEMS For example, if the fluid level is 1-2” below Refer to “Water Pump” for additional the FULL sensor, the monitor will show the level information on the water pump and initial start- to be only 2/3 even though the tank is nearly full. If a tank is about 1/4 full, the monitor will register an empty tank because the fluid level is below the 1/3 sensor even though there is still...
  • Page 42: Pressure-Temperature Relief Valve

    SECTION 4 - APPLIANCES AND SYSTEMS • The “DSI FLT” light will glow for about 10- 15 seconds, then it will go out. The “Heater On” indicator will remain lit. • If the “DSI FLT” light comes on during Water Heater Exterior Service Access operation, it means that the burner has gone into “lockout”...
  • Page 43: Furnace - Propane Gas

    SECTION 4 - APPLIANCES AND SYSTEMS • Lift handle straight out to open P-T valve when water heater is cold. 4. Let the handle of the P-T valve snap shut. Temp Selector buttons MODE 5. Close the faucet and turn on the water supply •...
  • Page 44: Ducted Roof Air Conditioning System

    SECTION 4 - APPLIANCES AND SYSTEMS We recommend that you provide AIR CONDITIONER FILTER adequate ventilation when using the furnace for the first time to avoid a The washable foam air conditioner filter is nuisance smoke alarm. located in the ceiling-mounted return A/C grille We do not recommend removing the in the lounge area of the motorhome.
  • Page 45: Propane Gas

    SECTION 5 - PROPANE GAS LP Auto Changeover System PROPANE GAS SUPPLY Turn on both LP supply cylinder valves. The The propane gas system supplies fuel for the indicator should be green when the cylinders are gas range/oven, water heater, and furnace (while full.
  • Page 46 SECTION 5 - PROPANE GAS • LP Supply (Main) WARNING Cylinder Valves This propane piping system is designed for use with propane only. Do not connect natural gas to this system. Securely cap inlet when not connected for use. After turning on propane, except after normal cylinder replacement, test propane piping and connections to appliances for leakage with soapy water...
  • Page 47: Safe Use Of The Propane Gas System

    SECTION 5 - PROPANE GAS problem may be air in the propane gas cylinder. • Never use a wrench to tighten the supply Air in the cylinder mixes with the propane gas valve. It is designed to close leak-tight by vapors causing them to burn poorly.
  • Page 48: Propane Gas Pressure Regulator - Removable Lp Tank

    SECTION 5 - PROPANE GAS • Never use an open flame to test for propane gas leaks. Replace all protective covers and DANGER caps on propane system after filling. Make sure valve is closed and door latched securely. • Portable fuel-burning equipment, including IF YOU SMELL PROPANE wood and charcoal grills and stoves, shall not 1.
  • Page 49: Propane Vaporization In Cold Weather

    SECTION 5 - PROPANE GAS This means that in extremely cold weather when a large volume of gas is being used by the furnace for heating, it is possible to experience a loss of gas pressure. At first, this problem may appear to be caused by an empty tank or a regulator freeze-up, but is actually caused by failure of the liquid gas to vaporize as fast as it is needed by the furnace.
  • Page 51: Electrical

    SECTION 6 - ELECTRICAL Your motorhome is equipped with an when the auxiliary electric generator is running, electrical system consisting of two separate the power converter automatically changes a voltages: portion of the 120-volt current to 12-volt DC current. All equipment in the motorhome that is •...
  • Page 52: Inverter Unit - 1000W

    SECTION 6 - ELECTRICAL be used is designed to mate with the prongs of the power fails, contact the park attendants and have power cord plug, the electrical connection can be them check the fuse or breaker for your supply expected to carry rated load.
  • Page 53: Power Center

    SECTION 6 - ELECTRICAL • Model 29L - Located beneath dinette. POWER CENTER Remove access cover in dinette seat. (Converter) • Model 31P - Located beneath sofa. Remove access cover. The power converter is generally located in a lower cabinet face in the galley or living area, depending on the floorplan of your model.
  • Page 54: Circuit Breakers - House 120-Volt Ac

    SECTION 6 - ELECTRICAL reset, take immediate steps to correct the cause of overheating. A portion of the house 12-volt load NOTICE (lights or motors or both) should be turned off to reduce total load. Also, inspect the power converter to ensure ventilation is not obstructed. Do not block the converter cover vents in any way.
  • Page 55: Electrical Outlets - House 120-Volt Ac

    SECTION 6 - ELECTRICAL –If Equipped • Push to Reset circuit after monthly testing WARNING or ground fault tripping. Careless handling of the generator and electrical components can be fatal. Never touch electrical leads or appliances when your hands are wet, or when standing in water or on wet ground.
  • Page 56: Electrical System - House 12-Volt Dc

    SECTION 6 - ELECTRICAL Generator Hourmeter NOTE: Check auxiliary generator oil level frequently during periods of use. This meter is located on the monitor panel. It registers the total number of hours that the Refer to the generator manufacturer’s generator has been operated. maintenance information in your InfoCase for specific recommendations.
  • Page 57: House/Coach Battery Disconnect Switch

    SECTION 6 - ELECTRICAL HOUSE/COACH BATTERY DISCONNECT SWITCH (COACH BATT) The House/Coach Battery Disconnect switch lets you disconnect the house batteries from the 12-volt system of your motorhome during storage periods to avoid battery drain by electrical items that are hooked directly to the house batteries, such as clock displays and radio memories, etc.
  • Page 58 SECTION 6 - ELECTRICAL The two best defenses against sulfating Further precautions are: and insufficient charge are to: • Check the state of charge periodically to avoid discharge or sulfating. 1. Turn off the House/Coach Battery Disconnect switch to avoid parasitic discharge (the trickle To ensure that the battery will always accept discharge caused by directly connected and hold a charge, follow these simple...
  • Page 59: Circuit Breakers And Fuses - House 12-Volt Dc

    Always replace fuses with those of the If your motorhome is going to be unoccupied same amperage rating. ® for two weeks or more, Winnebago Industries recommends disconnecting the chassis battery in your motorhome to avoid battery discharge. Disconnect the ground cable on the chassis battery (located behind a passenger side exterior door) to disconnect battery.
  • Page 60 SECTION 6 - ELECTRICAL Automotive Chassis and House 12-Volt Circuit Breakers A label on the Automotive Chassis and House 12-Volt Circuit Breaker panel states the amperage rating and circuit protected for each breaker. The circuit breakers are located inside an exterior compartment near the batteries.
  • Page 61: Plumbing

    SECTION 7 - PLUMBING Always fill the fresh water tank at an approved FRESH WATER SYSTEM potable water filling facility or a known purified drinking water source. The Fresh Water System provides water to the galley sink, shower, bathroom lavatory, toilet, The tank is filled through the City Water and water heater.
  • Page 62 SECTION 7 - PLUMBING (Located in water service center) (Located in water service center) 3. Turn city water supply ON. Using City Water 4. Use the level display on the monitor panel to When connected to an outside source of water, oversee filling of the tank, or when the tank is the water bypasses the water pump and storage full, water will flow from tank vent tube...
  • Page 63: Water Pump

    SECTION 7 - PLUMBING NOTE: Ensure the Fresh Water valve is in NORMAL position to use the water pump. If the valve is in Tank Fill position, the pump will run continuously without delivering water. Method 2 - Filling the Fresh Water Tank Through Gravity Fill (screw off/on removable plug) WARNING...
  • Page 64 SECTION 7 - PLUMBING Water Pump Strainer Do not leave the pump on while away from your motorhome or while driving. In time, a The pump is equipped with a cleanable slow leak in a faucet could drain the water tank, strainer to capture any possible tank-borne fill the holding tank, and discharge the house particles that could damage pump components.
  • Page 65: Disinfecting Your Fresh Water System

    SECTION 7 - PLUMBING NOTE: If a 100 ppm concentration is desired, use 1/2 cup of household bleach with 1 gallon of water to prepare the chlorine solution. One gallon of this solution should be used for each 15 gallons of tank capacity.
  • Page 66 SECTION 7 - PLUMBING hose and the city water fill to add disinfecting 2. Fill the tank completely, then open each faucet solution to the tank. These filters are commonly in the motorhome and run the water until a available at most RV supply stores. distinct odor of chlorine can be detected in the water discharged.
  • Page 67: Shower Hose Vacuum Breaker

    SECTION 7 - PLUMBING tank, this will result in a 6.7 ppm level of the holding tank. Toilet tissue made chlorine, which should kill harmful bacteria specifically for use in RV toilets and holding and slime-forming organisms. tanks is available at most RV supply centers. •...
  • Page 68 SECTION 7 - PLUMBING Turn the pump on as you begin to use the exterior sink and leave running to remove the water from the sink. Turn the pump off when the water is completely removed after using the sink. Sink Drain Strainer and Filter The sink drain has a strainer and filter to keep debris from entering the lines and damaging the...
  • Page 69: Waste Water System

    SECTION 7 - PLUMBING WASTE WATER SYSTEM Sewage Drain Outlet/Dust Cap (Holding Tanks) The drainage system is self-contained and uses two separate holding tanks to contain the waste water until it can be dumped at an appropriate waste water disposal site. This means you can use the toilet, sinks, and shower even in areas where utility hookups are not available.
  • Page 70: Waterline & Tank Drain Valves

    SECTION 7 - PLUMBING 7. Add an odor control chemical to the sewage holding tank through the toilet. These chemicals are available at most RV supply centers. 8. Rinse sewage drain hose thoroughly with • 2nd - Pull water before stowing. Gray Waste Tank Drain NOTE: We recommend that you dump all...
  • Page 71: Water Heater Bypass And Antifreeze Siphon Valves

    SECTION 7 - PLUMBING See the “Water System Drain Valve Locations” chart at the end of this section for locations on your model. D R A I N D R A I N C L O S E C L O S E L I N E - E N D V A L V E I N - L I N E...
  • Page 72 Then use a compressed air hose regulated to 30 psi or less to force air through the system. A blow-out plug can be Water Heater Drain Plug ® purchased at any Winnebago Industries (Remove with socket) dealer. -Typical View City Water...
  • Page 73 SECTION 7 - PLUMBING 8. Drain Toilet. Operate and hold toilet flush 15. Close dump valves and refit the dust cap onto lever until water is completely drained from the drain outlet. toilet. This will inhibit rust formation on valve shafts and prevent entry and contamination by 9.
  • Page 74 SECTION 7 - PLUMBING Locations” chart at the end of this section for valve locations on your WARNING model. Fill Lines Never use automotive antifreeze/coolant 5. Turn the Water Pump switch ON. in your RV water system. Auto antifreeze 6. Open each hot and cold water faucet handle in contains ethylene glycol which, if the motorhome - one at a time, until antifreeze ingested, can cause blindness and can...
  • Page 75 SECTION 7 - PLUMBING Fill Drainage System P-Traps 15. Pour about one cup of RV antifreeze down each drain for the galley sink, lavatory sink, and shower/tub. This fills the drain trap pipes to prevent holding tank odors from entering the motorhome during storage.
  • Page 76: Water System Drain Valve Locations

    SECTION 7 - PLUMBING WATER SYSTEM DRAIN VALVE LOCATIONS System Drain Valve Locations Waterlines • Two (2) waterline drain valves located in the passenger side compartment behind rear axle. Also, place the tip of your finger inside the city water connection and gently press the backflow valve (small “button”...
  • Page 77: Entertainment

    SECTION 8 - ENTERTAINMENT Further Information TV ANTENNA – DIGITAL See the antenna manufacturer’s user guide (Omnidirectional Digital HDTV Over-the- provided in your InfoCase for complete operating Air Antenna) and maintenance information. Your motorhome is featured with a omnidirectional digital antenna, which provides TV SIGNAL AMPLIFIER crystal clear digital HD reception of over-the-air The TV Signal Amplifier is built into the...
  • Page 78: Audio/Video System Connection

    TV. The HDMI Connection or Cable is located ® See your authorized Winnebago Industries inside a cabinet or mounted on a wall near the dealer for proper installation and sealing of roof bedroom or lounge TV.
  • Page 79: Wifi Prep Kit

    SECTION 8 - ENTERTAINMENT 1. Pull the black release strap (located on back WIFI PREP KIT side of TV) straight down to release the TV from the mounting bracket. There is a wallplate and a 110v receptacle located in the front overhead cabinet above 2.
  • Page 81: Furniture And Softgoods

    SECTION 9 - FURNITURE AND SOFTGOODS Dinette to Bed SLEEPING FACILITIES 1. Remove both dinette back cushions and set aside. WARNING Sleeping facilities are not intended for use while vehicle is in motion. For safety, passengers must use safety belted seating positions while vehicle is in motion.
  • Page 82 SECTION 9 - FURNITURE AND SOFTGOODS 4. Push table straight down. Lower dinette seat cushions. WARNING Failure to engage the lock rod when the table is raised may result in injury. Hi-Lo Table Operation 1. Depress metal buttons on both sides of the table, just under the edges 5.
  • Page 83: Sofa/Bed Conversion

    SECTION 9 - FURNITURE AND SOFTGOODS To return table to previous configuration, The Loft Bed is stowed near the cab ceiling as push table down until you hear a click. shown in the following photo. SOFA/BED CONVERSION –If Equipped (Typical View – Your motorhome may differ in appearance) Sofa to Bed •...
  • Page 84 SECTION 9 - FURNITURE AND SOFTGOODS Before Using Loft Bed Ladder • Inspect the ladder to make sure it is not damaged. Never use a damaged ladder. • Keep the rungs of the ladder clean and dry while in use. Do not step onto the rungs if the rungs are wet, or if your shoes are wet or carry debris that could result in a loss of footing.
  • Page 85: Pleated Blinds

    SECTION 9 - FURNITURE AND SOFTGOODS Tension Adjustment The tension of the pleated blinds can be adjusted if they become loose and will not stay up when raised, or they are too tight and are difficult to raise and lower. The tension cords are attached to spools at the lower corners of the blinds as shown in the following photo.
  • Page 86: Roller Shades

    No matter which species you chose for your new Winnebago Industries motorhome cabinetry, please keep in mind that no two pieces -Typical View of wood are exactly the same.
  • Page 87 SECTION 9 - FURNITURE AND SOFTGOODS Therefore, since wood is a product of nature and will have certain natural characteristics and variances, they are not covered under the warranty.
  • Page 89: Slideout Rooms And Leveling

    The ignition key must be placed in the on or run position to operate the slideout room(s). The park brake must be applied for the room(s) to run. Winnebago recommends running the engine whenever you run the slideout rooms in or out, the engine alternator should insure the rooms have adequate 12-volt DC power to operate correctly.
  • Page 90 SECTION 10 - SLIDEOUT ROOMS AND LEVELING To Retract Slideout Room Before Retracting! WARNING • Be sure the motorhome is level and the Parking Brake is set. CRUSH HAZARD. Keep people and • Ensure exterior compartment doors are closed objects clear of the inside and outside of the slideout room when operating.
  • Page 91: Slideout Room - Extreme Weather Precaution

    SECTION 10 - SLIDEOUT ROOMS AND LEVELING • Press the Slideout Room “RETRACT/IN” • The circuit breaker may be tripped. The switch and hold until the room is fully circuit breaker, labeled “Slideout Power” is retracted, then release the switch. located on a panel on an interior wall of the passenger side storage compartment just •...
  • Page 92: General Slideout Care

    SECTION 10 - SLIDEOUT ROOMS AND LEVELING operating guide included in your InfoCase for NOTE: When parking at an uneven site, always further instructions and troubleshooting park the front of the vehicle to the information. downhill side. This allows you to level by raising the front end rather than the rear.
  • Page 93: Checking Hydraulic Oil Level

    SECTION 10 - SLIDEOUT ROOMS AND LEVELING Jacks Down Light In The Event Of Accidental Jack Extension The “Jacks Down” reminder is intended to warn you to retract your Leveling Jacks before 1. Bring the vehicle to a safe and complete stop moving the vehicle.
  • Page 94 SECTION 10 - SLIDEOUT ROOMS AND LEVELING NOTE: Always clean away any dirt and debris from the top of the reservoir before removing the breather cap to avoid entry of debris and contamination of hydraulic oil in the reservoir, which could lead to pump failure or other problems.
  • Page 95: Maintenance And Storage

    • Have the sealant replaced if you notice any of attention. Delaying these repairs may allow water the above. Your local Winnebago Industries leakage and result in damage to interior ceiling dealer has the correct and necessary parts and and body panels, upholstery, etc., which is not experience to help you maintain your sealants.
  • Page 96: Exterior Finish

    SECTION 11 - MAINTENANCE AND STORAGE weight to the vehicle. This, in effect, reduces the undercarriage and the body of your amount of cargo you can carry and remain within motorhome after exposure to these types GVWR and GAWR limits. of conditions.
  • Page 97: Exterior Graphic Care

    SECTION 11 - MAINTENANCE AND STORAGE However, if a crack has opened up and the weave of the cloth is visible, this does represent a NOTICE threat to the integrity of the fiberglass and must be repaired or covered as quickly as possible to avoid penetration by moisture, especially in Never use a strong solvent such as freezing climates.
  • Page 98: Exterior Lights

    Use the following EXTERIOR LIGHTS cautionary lists as a guide when selecting ® Most Winnebago Industries vehicles have cleaning products to use on plastic parts. polycarbonate lenses on exterior lamps, which are very sensitive to a variety of chemical solvents and cleaners.
  • Page 99: Cabinetry - Cleaning

    SECTION 11 - MAINTENANCE AND STORAGE General Stains shades should be closed when the motorhome is parked for an extended As with any stain or contamination, the quick period of time. response is the best, especially when done in conjunction with the proper cleaner for the type of stain.
  • Page 100: Sink - Stainless Steel

    SECTION 11 - MAINTENANCE AND STORAGE • Sweep or vacuum floor daily (use a vacuum SINK – STAINLESS STEEL without a beater bar head.) Remove loose dirt ® with a soft brush or Swiffer type product. Care and Cleaning Instructions •...
  • Page 101: Bathroom

    SECTION 11 - MAINTENANCE AND STORAGE Treatment of Stains Tub and Shower Walls The tub and shower walls in the bathroom Acids, alkali, alcoholic beverages, coffee, soft should be cleaned with mild soap and warm drinks, ketchup, fruit, fruit juices, food, water.
  • Page 102: Vehicle Storage - Preparation

    SECTION 11 - MAINTENANCE AND STORAGE Door locks and hinges should be lubricated engine computer. periodically with powdered graphite to ensure 7. Have the vehicle chassis completely serviced trouble-free operation and to protect against and lubricated. Be sure radiator antifreeze freeze-up.
  • Page 103: Chassis Service And Maintenance

    SECTION 11 - MAINTENANCE AND STORAGE 8. Sanitize the water system as outlined under “Disinfecting the Fresh Water System” in Section 7 - Plumbing, then flush the waterlines thoroughly with fresh water. 9. Check the toilet for proper operation. 10. Add water to the holding tank using the toilet flush lever and galley sink faucet.
  • Page 104: Motorhome Maintenance Chart

    SECTION 11 - MAINTENANCE AND STORAGE MOTORHOME MAINTENANCE CHART These recommendations apply for normal recreational use. Heavy duty or full-time use may require more frequent maintenance intervals. Always use specified sections or manufacturer’s guide for further information and instructions. Propane Gas System ...
  • Page 105 SECTION 11 - MAINTENANCE AND STORAGE MOTORHOME MAINTENANCE CHART These recommendations apply for normal recreational use. Heavy duty or full-time use may require more frequent maintenance intervals. Always use specified sections or manufacturer’s guide for further information and instructions. Safety Equipment Check operation of the following items: Headlights, Taillights, and Marker Lights ...
  • Page 106 SECTION 11 - MAINTENANCE AND STORAGE MOTORHOME MAINTENANCE CHART These recommendations apply for normal recreational use. Heavy duty or full-time use may require more frequent maintenance intervals. Always use specified sections or manufacturer’s guide for further information and instructions. Sealants Inspect (see “Sealants - Inspection and General ...
  • Page 107: Miscellaneous

    SECTION 12 - MISCELLANEOUS NOTE: We recommend that you dump all LOADING THE VEHICLE holding tanks before traveling to avoid carrying unnecessary weight. NOTE: Your motorhome’s load capacity is designated by weight, not by volume, so you cannot necessarily use all available space when loading your motorhome.
  • Page 108 SECTION 12 - MISCELLANEOUS Corner Weighing (Side-to-Side) You will first drive only your front wheels onto the scale pad, then drive ahead so that the The most accurate method of weighing a whole vehicle is on the scale, then finally pull off motorhome is to weigh each “corner”...
  • Page 109: Car Or Trailer Towing

    SECTION 12 - MISCELLANEOUS axle is 12,000 lbs., then the load on each rear dual listed Gross Weight Ratings. See “Vehicle set (left rear duals or right rear duals) should not Certification Label” in the Introduction section exceed 6,000 lbs. for information on gross weight ratings.
  • Page 110: Trailer Wiring Connector

    SECTION 12 - MISCELLANEOUS located outside our recommended limits) places The following diagram shows proper excessive stress on the hitch. This abuse of the connection of trailer or tow vehicle wiring to the ball mount and the hitch may cause premature motorhome light system.
  • Page 111: Step (Entry) - Electric

    (hinge side) of the screen door. ® NOTE: Some Winnebago Industries models equipped with a Class 3 hitch may have a label limiting vertical tongue load to 350 lbs. Some Winnebago Industries models 12-5...
  • Page 112: Power Roof Ventilator

    SECTION 12 - MISCELLANEOUS Automatic Mode - Entry Step This feature is intended to prevent injury or damage by an extended step while the vehicle is Switch ON moving. (Step Operates with Door) With the Step switch in the ON position, the Further Information step is in Automatic Mode.
  • Page 113: Windows

    SECTION 12 - MISCELLANEOUS WINDOWS AWNING – POWER –If Equipped Horizontal Slider Windows The Power Awning and Awning Light –If Equipped switches are located near the entrance door. Swing the latch handle straight out or up (depending on the style of window). Grasp the Awning Light sliding window edge frame and slide the window Switch...
  • Page 114: Storage Compartment Doors

    SECTION 12 - MISCELLANEOUS Further Information the rungs are wet, or if your shoes are wet or carry mud or debris that could result in a loss For complete operating instructions, features, of footing. safety precautions, and maintenance care, refer to the Power Awning manufacturer’s information •...
  • Page 115 SECTION 12 - MISCELLANEOUS When you recognize the signs of excessive moisture and condensation in your motorhome, you should take immediate action to minimize their effects. You can help reduce excessive moisture inside the motorhome by taking the following steps: Ventilate with outside air Partially open one or more windows and a roof vent to circulate outside air through the...
  • Page 117 INDEX About this Manual ..........................1-1 Air Conditioner Filter ..........................4-8 Air Conditioner/Heater – Automotive (Dash) ..................3-7 Audio/Video System Connection ......................8-2 Awning – Power ........................... 12-7 Bathroom .............................. 11-7 Battery Access ............................6-7 Battery Boost Switch ..........................3-7 Battery Care ............................
  • Page 118 Index Exterior Entertainment Center (Adjustable) ................... 8-3 Exterior Finish ............................11-2 Exterior Graphic Care ........................... 11-3 Exterior Lights ............................11-4 Fire Extinguisher ............................. 2-6 Formaldehyde Information ........................2-9 Fresh Water System ..........................7-1 Front Axle Tire Alignment ........................1-2 Front Drop-Down Shade (12-Volt) ......................3-6 Front Service Access ..........................
  • Page 119 Index Pressure-Temperature Relief Valve ......................4-6 Propane Gas Leak Detector ........................2-4 Propane Gas Leaks ..........................2-4 Propane Gas Pressure Regulator – Removable LP Tank ................ 5-4 Propane Gas Supply ..........................5-1 Propane Gas Warnings and Precautions ....................5-3 Propane Vaporization in Cold Weather ....................5-5 Radio In-Dash/Rearview Monitor System ....................
  • Page 120 Index Systems Monitor Panel ........................... 4-4 Tables and Countertops ........................11-5 Tires ..............................3-10 Toilet ............................... 7-7 Tow/Haul Transmission Mode ....................... 3-6 Towing Guidelines ..........................12-4 Traction Control Button .......................... 3-7 Trailer Wiring Connector ........................12-4 TV Antenna – Digital ..........................8-1 TV Digital Satellite System Wiring ......................

Table of Contents

Save PDF