4006/8 Diesel, May 1998 - Perkins 4006 User Handbook Manual

WIRING DIAGRAM WITH HEINZMANN GOVERNOR & PRESTOLITE STARTER FOR
MANUAL OR AUTOMATIC START
Key
(Fig. 53)
1. Charge alternator (CAV)
1A.Charge alternator (BUTEC)
2. Oil pressure switch
3. Water temperature gauge
4. Oil temperature gauge
5. Oil pressure gauge
6. Ammeter
7. Tachometer
8. Fuse
9. Key switch if required
10. Governor actuator
11. Resistor
12. Sender water temperature
13. Sender oil temperature
14. Sender oil pressure
15. Governor control box
16. Fuel solenoid energised to run
17. Magnetic pick-up
18. Engine flywheel
19. 24 volt starting batteries
20. Starter motor
21. Start relay
Fig. 53
54
22. Fuel solenoid relay
23. Combined engine faults switch
24. Water temperature
25. Oil pressure
26. Two switch speed unit
27. Switch 2 overspeed
28. Switch 1 speed ref
29. Wire sizes
30. To enable engine to run immediately on
depressing start button both FPS and GOV+
must be fed 24 volt +ve. To stop break thus
+ve supply
31. Typical terminal block
32. Speed trim pot
33. If speed trim pot is not required remove
and connect thus

4006/8 Diesel, May 1998