Preventive Maintenance; Routine Cleaning Requirements; Daily Oven Cleaning - Alto-Shaam 6-10ML Service Maintenance Manual

C O M B I T H E R M

2.3 Preventive Maintenance

In addition to the routine cleaning and maintenance procedures, there are several additional steps to be
taken for both sanitation purposes and to keep the oven running at top operating efficiency. These
additional safeguards will help prevent inconvenient down time and costly repairs.
G DO NOT DISPOSE OF GREASE, FAT, OR SOLID WASTE DOWN THE OVEN DRAIN. Fats and solids will
eventually coagulate in the drain system, causing blockage.
G MAKE CERTAIN THE DRAIN SCREEN IS ALWAYS IN PLACE. REMOVE ANY SOLID WASTE MATERIAL FROM
THE DRAIN SCREEN BEFORE IT ENTERS THE DRAIN SYSTEM. The routine removal of solids from the
drain screen will help prevent blockage.
G USE THE AUTHORIZED COMBITHERM OVEN CLEANER ONLY. The use of unauthorized cleaning agents
may discolor or harm the interior surfaces of the oven.
G TO PROLONG THE LIFE OF THE DOOR GASKET, REMOVE AND CLEAN THIS ITEM DAILY.
The acids and related compounds found in fat, particularly chicken fat, will considerably
wea ken the c om posi t i on o f the ga ske t u n l e ss cl ean e d on a da i l y basi s .
G TO ADDITIONALLY PROTECT GASKET LIFE, ALLOW OVEN DOOR TO REMAIN SLIGHTLY OPEN AT THE END
OF THE PRODUCTION DAY. An open door will relieve the pressure on the door gasket.
G ROUTINELY CLEAN DOOR HINGES. Open oven door to relieve tension. Clean all parts of the hinge.

2.4 Routine Cleaning Requirements

DAILY OVEN CLEANING

To be performed at the end of each production day or between production shifts.
M O N T H LY C L E A N I N G
D A I LY G A S K E T C L E A N I N G
It is important to prolong the life of the oven gasket by cleaning this item on a daily basis. Routine cleaning
will help protect the composition of the gasket from deterioration caused by acidic foods. After allowing the
oven to cool, remove pull-out gasket and wash in hot, soapy water. Do not place in the dishwasher.
Always replace the gasket before cleaning the oven interior or operating the oven.
. 1 9
P G
C L E A N I N G & M A I N T E N A N C E
®
W AT E R I N TA K E F I LT E R
D R A I N P I P E
F L U E O U T L E T
C O M B I T H E R M G A S I N S TA L L AT I O N A N D M A I N T E N A N C E M A N UA L
F A N
— 6 4 7 0
M L